Thomas Hdx 2000
Model Hdx made in 2000 by Thomas got 1 investigation there is 1 recall as well as 4 service bulletins. Technical service bulletines regarding equipment, service brakes, air and structure. The car had one investigation (structure). There was one recall concerning service brakes, air .
Model 2000
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, AIR | ||||||||||||||||
07V137000 | FREIGHTLINER LLC | from 04/23/2000 to 11/14/2003 | V (Vehicle) | 3000 | 02/29/2008 | ODI | THOMAS BUILT BUSES, INC. | 03/23/2007 | 03/23/2007 | |||||||
Defect Summary | Certain my 2000 through 2003 thomas built hdx and mvp-er school buses manufactured between april 23, 2000, and november 14, 2003. the service air brake pedal, for both non-adjustable and adjustable brake pedals, may contact the front structure on the bus, limiting the maximum brake force available. | |||||||||||||||
Consequence Summary | Insufficient air brake pressure may cause extended stopping distances without prior warning, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Thomas built will notify owners and repair the affected buses free of charge. the recall began on september 14, 2007. owners can contact thomas built at 336-889-4871 or contact freightliner at 800-547-0712. | |||||||||||||||
Notes | Freightliner recall no. fl-493.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL | |||||
PSD-302B | 07/30/2008 | 10034604 | Thomas built: it has been determined that certain model buses, er-hd, hdx and mvp-ef units, have the von #70 s-cam brackets that could develop cracks in the lower portion. *pe | 12/10/2010 | |
SERVICE BRAKES, AIR | |||||
PSD-302B | 07/30/2008 | 10034604 | Thomas built: it has been determined that certain model buses, er-hd, hdx and mvp-ef units, have the von #70 s-cam brackets that could develop cracks in the lower portion. *pe | 12/10/2010 | |
STRUCTURE - BODY - DOOR | |||||
51R3 | 02/14/2008 | 10025902 | Thomas built buses: there have been reports of the forward door leaf hex shaft breaking. *pe | 09/15/2008 | |
STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | |||||
51R3 | 02/14/2008 | 10025902 | Thomas built buses: there have been reports of the forward door leaf hex shaft breaking. *pe | 09/15/2008 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | ||||||
PE07054 | THOMAS BUILT BUSES, INC. | 11/09/2007 | 03/04/2008 | EMERGENCY DOOR HANDLE FAILURE | 08V087000 | |
The office of defects investigation opened this preliminary evaluationafterbecoming aware that fleets were having handle failures on the rear emergency door exit.the failure resulted in the door handle separating from thedoor latch mechanism.when the handle fails, the rear emergency exit door can not be opened from outside the bus.the failure results from corrosion of the exterior door handle around the securing roll pin and square drive latch mechanism, causing the protective finish to chip and flake.continued corrosion weakens the handle and eventually the handle may break while trying to open the exit door.odi was concerned that during an emergency, a person outside of the bus would break the door handle while trying to open the emergency exit door,potentially delaying evacuation of the bus.under the safety recall, the aluminum handles will be replaced with a more robust handle.the recall action resolves the issues raised by this investigation. accordingly, this investigation is closed. |