Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||||
| 5103 | 11/08/1999 | 5103 | 6089462 | Information regarding new rear brake pads and calipers. *tt | 02/03/2000 |
| 5103 | 07/22/1998 | 6089495 | Introduction of new rear brake pads and calipers. *tt | 02/03/2000 | |
| 5104V2 | 05/28/1999 | 5104 | 606242 | Subject on the cross-shaped pad retainer spring in the rear calipers coming in contact with the rotor. *tt | 08/13/1999 |
| 5104 | 01/12/1999 | 604723 | Concerns with the cross-shaped pad retainer spring in the rear calipers can come in contact with the rotor. *tt | 05/10/1999 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES, AIR - ANTILOCK | |||
| 05/15/2002 | 100 | 08/01/2001 | |
| In normal driving conditions, the anti-lock brakes will engage sometimes without even touching the brake pedal. (ie. on accelerating) following this, the abs and tracs light comes on. when this condition presents itself during normal braking conditions, the brakes get soft from anti-locking pulses until the computer finally recognizes the error and realizes that in fact there is no need to engage anti-lock system, after which regular braking may resume. dt | |||
| 08/01/2002 | 15 | 12/01/2098 | |
| I had this problem diagnosed and repaired incorrectly at laurel jaguar volvo of tinley park, il., at a cost of $341.00. the problem persists. i do not think that i should have to pay additional money to correct a safety problem such as this. dt | |||
| 10/01/2002 | 50 | 09/01/2000 | |
| Abs light comes on all the time, vehicle had to have abs computer replaced. i was told by volvo repair shop, they are getting a minumum of 2-3 a month with exact same problem defective computer. dt | |||
| 10/01/2002 | 2 | 12/01/2098 | |
| Abs and traction control failed. mr | |||
| 09/01/2002 | 1 | 11/01/2098 | |
| The abs control unit failed. the abs is disabled by the failure. a new abs control unit is on order at the volvo dealer. it is covered by warrenty. i'm reporting this as a safety issue because the abs system is a safety system and it should not fail due to a defective part. although not valid for your data collection, i can say i know other people with the same volvo who have had the same problem. mr | |||
| 07/28/2002 | 1 | ||
| The vehicles abs module failed. *mr volvo refuses to cover parts and labor, the dealer stated that the abs failure was not a safety issue. *scc | |||
| SERVICE BRAKES, AIR - ANTILOCK - ABS WARNING LIGHT | |||
| 09/09/2003 | 90000 | 04/16/2003 | |
| Abs/tracs lights comes on and off indicating a brake module malfunction | |||
| 09/01/2003 | 20 | ||
| Abs and tracs light turns on and off randomly while driving. affects the brakes because abs is disabled and also activated during driving. this issue has been widely discussed in online forums, and is also well-known to dealers throughout the world. the problem is due to a failure in the abs/tracs control unit.*ak | |||
| SERVICE BRAKES, AIR - ANTILOCK - CONTROL UNIT/MODULE | |||
| 11/18/2003 | 137400 | 1 | 01/14/1998 |
| My 1998 volvo s70 had the abs module failed. this seems to be a very common problem with the car. had this failed in rain or snow, the consequences could have been terrible.*ak from what i have read, this is a known problem by volvo, but they refuse to fix it. the cost is outrageous, over $600. | |||
| 09/10/2003 | 78000 | 1 | 06/20/1998 |
| The abs light comes on and off intermittently. my technician says it is a faulty abs controller. i have seen several posts on brickboard.com in reference to the same problem. it appears to me that volvo has released a car with an obvious defect. *ak | |||
| 08/05/2003 | 65000 | 25 | 09/09/1999 |
| Rear passenger wheel sensor for the abs, shows needed replacement. the sensor replacement does not correct the problem. the auto tech researched from a common auto technichians web page and found this to be a common problem for the s70. the problem lays with a faulty computer on the vehicles. as a result the abs does not operate. 1998 volvo s70t. | |||
| 09/01/2003 | 59000 | 1 | 04/27/2001 |
| Abs computer chip was bad and needed to be replaced. my car has fewer than 60,000 miles. this component was not covered by the extended warranty and cost over $600 to replace. i have heard this is a common problem. if failure of the abs chip is as common as i'm told, then i believe volvo should pick up the cost for replacing this defective component in their vehicles.*ak | |||
| 09/01/2003 | 20 | ||
| Abs and tracs light turns on and off randomly while driving. affects the brakes because abs is disabled and also activated during driving. this issue has been widely discussed in online forums, and is also well-known to dealers throughout the world. the problem is due to a failure in the abs/tracs control unit.*ak | |||
| 11/10/2002 | 97000 | 10 | 03/12/1998 |
| Asb/tracs module failure on my 1998 volvo s70 | |||
| SERVICE BRAKES, AIR - CONTROLS | |||
| 01/28/2003 | 60 | 3 | 10/01/1998 |
| The cruise control turns off automatically, and without warning, causing a fairly rapid deceleration. sometimes, cruise control will not set. | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 05/12/2005 | 11/01/1998 | ||
| Dt anti-lock brake system contact states each time the brakes are applied the vehicle is more difficult to stop and the wheels have also locked up. transmission contact states the vehicle make a squeaking nose when parking, the vehicle pulls to the right side when driving at low speed. engine and engine cooling contact states oil moves up through the ignition control. the vehicle has been taken to a service dealer and the mechanic stated the vehicle needed a new engine. *nm *sb | |||
| 06/15/2001 | 1 | 10/01/2000 | |
| The abs/tracs failure was due to a $500 printed circuit board in the engine compartment area. the mechanic says that it is a problem known to many, as there have been a rash of them in the last year. dt | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 08/13/2005 | 60000 | 1 | 09/03/1999 |
| Abs brake unit failed at 60k miles; all service was done at dealer. dozens and dozens of owners have reported this to nhtsa for exact same make and model. nhts seems powerless to take on this issue. how many deaths will it take to get some action? volvo dealers and ford know well the problem -- just count the cash they are making on the replacements, and then multiply by 10 because most are not willing to pay $1,000 for a $200 part. *nm | |||
| 12/18/2006 | 78000 | 1 | 08/01/1998 |
| Dt*: the contact stated while driving various speeds, the antilock brake light intermittently illuminated. the vehicle was inspected by a dealer who determined while the light was illuminated, there was a failure of the antilock brakes. also, the dealer determined the computer needed to be replaced. the manufacturer was alerted. | |||
| 09/20/2006 | 76000 | 1 | 07/02/1997 |
| Dt*: the contact stated the abs and traction control lights on the dash illuminated causing both components to be inoperable. this occurred intermittently. the vehicle was driven to the dealer who determined both systems needed to be replaced. updated 10/31/2006 -*nm | |||
| 04/15/2005 | 119000 | 100 | 06/05/2000 |
| Intermittent failure of the abs/tracks system - well known/documented defect. volvo parts center says cause was faulty abs units from the philippines. this causes a failure of the abs system, yet volvo does not recall?. *jb | |||
| 10/11/2004 | 113500 | 2 | 07/24/1997 |
| Abs/tracs failure. *nm | |||
| 11/30/2002 | 55000 | 1 | 11/20/2001 |
| Abs and trac lights work only part of the time. lights for these features usually light up after an odd, one-second humm. *jb | |||
| 05/01/2003 | 74000 | 1 | 07/31/2001 |
| My wife's 1998 volvo s70 had 74,000 miles when her abs and tracs warning light came on. after taking it into the volvo dealership it was assessed that the abs/tracs is not working because of a failure of the abs/tracs control module. after some research i found a large number of people having the same issue when their same model car reached anywhere between 50 and 100 thousand miles. this is a serious safety concern and volvo should recall and replace the part. *jb | |||
| 12/01/2002 | 72000 | 1 | 09/04/2000 |
| The abs light was coming on intermittently. after consulting the web i learned this was a common problem in the 98 s70's. volvo is aware of the problem! while driving with the condition i noticed if the abs pump cycled and the lights come on you lose braking unless you pump the brakes. extremely dangerous condition for a many drivers. i'm a law enforcement officer and my training helped me avoid the accident. *nlm | |||
| 11/22/2002 | 5 | 11/01/2099 | |
| Brake pedal pulsating, car making noises when brakes applied normally in heavy traffic. abs/tracs light came on. the noise and failure light have occurred several times. dt | |||
| 11/06/2002 | 1 | 03/01/2000 | |
| Abs control module failed after only five years and less than 50,000 miles and volvo or the vip extended warranty will cover the cost of part replacement or. dt | |||
| 10/01/2002 | 1 | 09/01/2098 | |
| No summary. dt | |||
| 10/05/2002 | 1 | ||
| Abs light comes on and off randomly. been told by volvo dealer that it is a bad abs module. dt | |||
| 10/07/2002 | 3 | 07/01/2000 | |
| This seems to be a common problem with these models (98 s70), i was encouraged to report here because volvo na is not responding to customer complaints. abs dash light illuminates intermittently, sometimes resets correctly upon ign. off and restart, sometimes not. while light is illuminated, abs non-functional. mr | |||
| 10/03/2002 | 07/01/2001 | ||
| Abs module on the car failed. while driving, the abs light came on and upon taking it to the dealer, i was told that the abs module had to be replaced at a cost of $615. the car is a certified per-owned with less than 60k miles. the module should not have failed and by reading the other complaints, it seems to be a common issue on the 1998 s70 models. mr | |||
| 07/05/2002 | 11/01/2097 | ||
| Problem reported to dealer and volvo na. critical part of safety system, out of warranty, $553 repair cost. known defect in s/v/c 70 series. *ak | |||
| 08/13/2002 | 12/01/2098 | ||
| Abs is working only some of the time (volvo of las vegas has concluded that abs module is faulty and needs to be replaced). you never know at which point when you are driving that the abs decides not to function anymore. braking can become quite worrisome and frightening abs is a critical safety component of the car and volvo has failed to correct this problem. the sporadically functioning abs system can become very dangerous and cause a serious, if not fatal accident. volvo stands for safety and they should stand behind their product. this faulty abs module has become a major problem for 1998 s70's. i believe the nhtsa should mandate a recall.*ak | |||
| 07/01/2002 | 1 | 12/01/2099 | |
| While driving, i noted that the abs light was on. the next trip in the car, the abs sign was still on. i waited because intermittently various lights come on my dash, disappear, and never reappear. i went to the dealer to verify the failure of the abs. the dealer affirmed the failure and replaced the abs. the car is a 1998 s70. two of my coworkers have discovered that they have to have their abs replaced, within one month of my abs failure. one coworker has a volvo that is the same year as mine; the other car is a year or 2 older. this sounds like manufacturer planned obsolescence to me. how could this be a coincidence? i bought this car because of its reputation for reliable sturdy structure and safety and i am disappointed.*ak | |||
| 08/29/2002 | 1 | 05/01/2097 | |
| No summary listed for above vehicle. *ak | |||
| 08/15/2002 | 1 | 05/01/2097 | |
| I purchased this car in may 1997 and the warranty expired in may 2001. in july of 2001, i noticed that the abs warning light on the dashboard would intermittently flash on and off. it did not seem to affect my regular braking. at my next oil change in december i reported this problem to the dealer. they checked it out and found no problem. now a year later i found that the abs light was staying on for longer and longer periods, but it was still intermittent. i brought the car in this month while the light was on. they tested it with the computer and found that the abs control module had failed. besides being a $600 item, this meant that whenever the light was on, which was often over the last year, i actually had no abs function although i had no way of knowing it. i have since spoken to other volvo owners who have had the same problem with intermittent failure of this module. i am reporting this because i feel that this is a defective part made by volvo, and very dangerous. if someone is on an icy surface and steps on the brakd hard to activate the abs, they will be shocked to find out the the system has failed because the abs warning light is on. this module should last for the life of the car. *ak | |||
| 09/10/2001 | 09/01/2001 | ||
| This is a common, expensive, and potentially dangerous failure on 1998 volvo 70-series.. *ak | |||
| 04/20/2002 | 1 | 01/01/2099 | |
| The control module for the abs system has malfunctioned and must be replaced in order for the abs system to work. the repair shop owner indicated that this problem is common for this type of volvo and that his small shop had replaced 8-10 of them. the car remains driveable, but i have been advised that until the control module is replaced, i run the risk of rotor damage, as well as not having the use of the abs. i contacted volvo and was advised to contact nhtsa. please advise if you have received other complaints and if i have any recourse. thank you.*ak | |||
| 03/03/2002 | 10/01/2000 | ||
| Abs system intermittently activates upon braking, engine light comes on but dealer and other service organization unable to locate cause despite error code. *ak | |||
| 11/16/2001 | 1 | 07/01/1997 | |
| Over maximum 30 second period, vehicle bucked, then interior lights came on and began blinking, then throttle stuck in full position, then brakes failed completely while black smoke emerged from under hood and wheel wells, then flames visible from from grill over hood of car, then vehicle finally brought to stop using emergency brakes at which time flames were two-three feet high from grill and wheel well(s) area of car - exited immediately - car total loss ..... have since been made aware of another '98 s70 fire with very similar sequence of failure events and result - volvo contacted and claims evidence of animal nest under hood (assistance denied) - cinncinati insurance (my carrier) hired & conducted professional/independent fire investigation with results pending ...... have full set of photos - general comment: if there were an elderly person, diabled person or child strapped in childseat riding in vehicle, unable to react/move so quickly, results could have been catastrophic!!!!! | |||
| 09/28/2001 | 1 | 03/01/1998 | |
| I am aware of 2 other people who own this same vehicle (yr. make and model). all have the same part that has gone bad in the last month. the 2 dealers i've contacted say that there is a long waiting list for this part! you're just supposed to drive the car until they can get it (not knowing if you have abs or not i supposed)! also another deceptive/dangerous part of this problem is that the dash board warning lights are inconsistant. on some trips it comes on and on others it doesn't. it never stays on. you'll never know if you should pump the brakes in an emergency or not!*ak | |||
| 10/20/2001 | 1 | 06/01/2000 | |
| Selling dealer and manufacturer-provided extended warranty company refuse to underwrite $750 expense of replacement. dealer acknowledges that 7 similar cars are currently awaiting replacement of the same control unit. no safetyd efec tlisted. *ak | |||
| 1 | 06/01/1998 | ||
| With approximately 57,000 miles on the odometer i started experiencing severe vibrations when i applied the brakes stopping in a straight line and when turning left at speeds approximating 15-20 miles an hour. the dealer told me that the front rotors were warped because they are aluminum and warp if they get wet when they are hot. duh! this is florida, how can they not get hot & wet? the rear rotors were replaced at approx 30,000 miles.deel is currently replacing the rack & pinion steering assembly which apparently caused the severe vibrations when turning left & braking. this car has been maintained at deel volvo in accordance with the manufacturers guidelines.*ak | |||
| 04/01/2000 | 9 | ||
| During braking at slow speeds intermittently there is a loud pop. then, pedal goes to floor, resulting in extended stopping distance. vehicle taken to dealer 8-9 times. replaced brake pads twice, found lots of black dust, but stated that was normal. problem not remedied. *ak | |||
| 04/26/1999 | 08/01/1998 | ||
| At about 10,000 miles the brakes would slip and rumble when braking down a hill. i took the car in to complain and they told me that they couldn't find anything wrong with it. i started avoiding hills. every time i brought the car in for service i complained about this problem and was assured that nothing was wrong. now i am at 28300 and i took the car in for my 30,000 maintence, not at the dealer but another certified volvo shop. i tell them about the problem. i am told that the rotor is bad. well i had this same problem at under 10,000. miles.*ak | |||
| 09/05/1998 | 20 | ||
| I believe the information is self explanatory. thank you. my situation has been escalated to the manufacturer who over the past 6-7 weeks has been extremely unresponsive to my requests to establish meeting. no safety defect listed in summary. *ak | |||
| 05/18/1999 | 1 | 05/01/1997 | |
| Intake vent port blew out, also, lost braking. | |||
| 08/16/1997 | |||
| Driving down the highway when there was spontaneous increase in rpm without having foot on gas. brakes locked up on vehicle. cause of the problem is unknown.*ak | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||
| 07/17/2007 | 1 | 02/02/2001 | |
| I have a 1998 volvo s70 which has abs/trac light problems. i've been having intermittent issues with this where the indicator lights come on and the abs will sometimes pulsate and it makes a terrible noise. my understanding is that when the abs indicator is on, i don't have abs brakes. it appears from the volvo brickboard that a lot of people are having this issue. i am concerned about the safety (besides the fact that it is scary when the brakes start going) and think volvo should make the necessary repairs. it appears to be an issue only on this year/make. *tr | |||
| 09/04/2003 | 42000 | 1 | 07/30/1998 |
| My 1998 volvo s70 has 43,000 miles on it and the abs light comes on and off, and sometimes you feel in the brake pedal. after talking to other volvo owners they have had the same problem *la | |||
| 06/01/2003 | 96000 | 1 | 08/15/2002 |
| Abs light works intermittently. i was told i needed to replace my abs unit as is was faulty but abs light on the dash doesn't always turn on.*ak | |||
| 11/09/2002 | 158012 | 4 | 11/01/2002 |
| Abs & trac light come on when brakes get hot! *jb ************dimsii ivoq entry posted after 12/12/02 cut-over to artemis********769743 | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - CONTROL UNIT/MODULE | |||
| 10/23/2005 | 73000 | 1 | 09/30/2005 |
| The abs antilock brake system in my 1998 volvo s70 failed. the dashboard light indicated abs & traction control (tracs) failure. normal non-abs braking remained. research on several volvo owners web sites (such as brickboard: http://www.brickboard.com/awd/?model=s70) showed systemic failure of the abs control module volvo part # 9162675 due to printed circuit board solder cracking after 6 years. the car was tested by a volvo dealer confirming abs control module failedure. volvo charges a total $650 to replace the unit. the brickboard owners group suggested a repair shop in california that resolders the circuit board, replaces and upgrades failed components, tests & returns it for $130 plus shipping. we had the old board repaired, since a new exact replacement board from volvo would have the same failure after another 5 years. the repaired abs control unit has been reinstalled & the car now works properly, with full abs and tracs control. this is not the first printed circuit failure from volvo. our 1993 volvo 940 turbo had two board failures: 1, the relay base board solder cracked, and resulted in the overdrive relay not working; 2, cruise control operated erratically, due to bad board solder. both of these boards were repaired by our local service shop. we are very concerned that two critical safety elements - the abs system and traction control - are failing in a relatively short period of time, & because of a failure of what should be a simple assembly of tested parts. further, we are most disturbed that volvo's remedy is a very expensive replacement, with the same failure prone part. worse, although we opted for a complete repair, there are owners who cannot afford the fix. these will be driving with far less braking and control than the car is capable of providing. *nm | |||
| 08/23/2005 | 112027 | 1 | 07/16/2004 |
| Abs and tracs off indicator lights are on. dealer diagnosed as failing abs control module. dealer stated that abs does not work while indicator lights are on, but brakes do. with indicator lights on, the safety feature of anti-lock brakes and traction control are compromised. | |||
| 01/15/2005 | 117000 | 5 | 10/30/1998 |
| Dt: the vehicle was losing power, it shuts down. usually it will start back. can cut across traffic, and it will just stall. took it to the dealer many times, and they could not duplicate the problem. they put different parts on it to narrow down the problem. there is no power steering after it stalls. back in january the turbo went it out and they replaced it. the vehicle was still skipping. this started happening around january 15, 2005. *nm the abs control module was replaced. *jb | |||
| 06/01/2002 | 20000 | 24 | 05/01/1999 |
| Upon applying the brakes there was a humming noise/vibration that did not allow the brakes to respond. there was a problem in the computer that engaged the abs brakes. *ak updated 8/9/2006 - *nm | |||
| 09/04/2004 | 80200 | 06/15/1998 | |
| Volvo abs brake modular failed. local volvo service center aware of problem. *nm | |||
| 07/17/2004 | 98000 | 1 | |
| Rotors, brakes and struts replaced at approximately 100,000. abs controller fault diagnosed at dealer. failure led to loss of all antilock brake features as well as tracs. replacement of abs controller module recommended.*ak | |||
| 12/01/2002 | 95000 | 0 | 08/14/2002 |
| Abs light coming on and off intermediately, told by technician that abs module is bad and needs to be replaced at a cost of $600 plus. the problem is since this is intermittent that when the unit test itself when your braking if it notices that they aren't working many times the brake pedal goes to the floor, which could be very dangerous. when i spoke to volvo north american they said yes this is a common problem, but will not fix it. *nm | |||
| 05/24/2004 | 80000 | 1 | 10/01/1998 |
| Abs module fails on most all 850 and s/v70 series cars 97-00. the abs system as well as the traction control system will not work when the unit is failing. it is an intermittant problem that gets worse over time (sometimes the fail indicator is on sometimes not). volvo is well aware of the problem and a replacemet is around 500.00 not including diagnostics and labor to install. to my knowledge their is no recall (from a company that prides itself on safety).*ak | |||
| 06/16/2003 | 48000 | 1 | 03/23/2000 |
| Failure of abs controller module. my research over the internet and numerous volvo certified technicians indicate this failure is problematic with the teves 20 abs module. an internet forum page dealing with the volvo 850/s70 models is littered with inquiries into this problem. one volvo technician i corresponded with indicated he had replaced hundreds of these modules over the last several years. *la | |||
| 07/18/2003 | 85000 | 100 | 05/22/2000 |
| The abs system controller is defective on my 98 volvo s70 with 90k miles. under very light braking at slow speeds the abs will engage for no apparent reason and the remainder of the time it fails completely. i am told it is a chronic condition with this model and is a serious condition. *jb | |||
| 05/06/2003 | 70000 | 1000 | 01/03/1998 |
| I have a 1998 volvo s70 t5. the anti-lock brake controller board is malfunctioning causing the anti-lock brake red indicator light to come on at various random times while driving the car. when this happens, the brake pedal depresses on its own and many noises are heard around the area of the front left tire and the anti-lock brakes stop working while the light is on. this happens very frequently (at least once every time i drive the car). *jb | |||
| 05/03/2003 | 75000 | 1 | 05/31/1998 |
| The abs / tracks warning light has been coming on intermittently for the past year. initially in 2002 the dealership was not able to provide us with a definitive diagnosis, but without looking at the car, said that it was the abs control unit for $1000+. we declined the repair on the basis that it was a guess. on may 1, 2003, while in for routine service, the diagnosis was the abs/tracks control unit at a cost of $1000+. i entered 1 failure on today's date but numerous times the abs brakes engage when the brake pedal is not being touched and sometimes engages when the brakes are applied at slow speeds in non-emergency stopping. the dealership told me that the abs brakes will not work in an emergency situation. i have seen numerous complaints on the nhtsa website which leads me to believe the abs problem is widespread as probably less than 1% of car owners know to file a report. i estimate that 50% of 1998 volvos have this problem at 50000+ miles. i consider this a serious safety issue as a driver will rely upon the abs in an accident and will apply the brake pedal accordingly. if the abs don't function, the wheels will lock and possibly cause the driver to lose control of the car. the other safety issue is the abs engaging when the brake pedal is not applied or when the abs engage in non-emergency stopping. this is not controlled braking and could also cause an accident by alarming and confusing the driver. we bought the volvo after being hit by a drunk driver at 100+ mph and can't afford to sustain further serious injury or the stress caused by worrying about safety equipment failure on what is considered to be the safest car on the road. please address this very serious issue. thank you.*jb | |||
| 03/22/2003 | 30752 | 0 | 05/29/2000 |
| Abs ecu unit defective. abs light comes on intermittently. when abs light is on abs is not functioning. volvo warranty will not cover replacement. difficult for dealers to diagnose. *nlm | |||
| 01/01/2003 | 1 | ||
| Abs module on my 1998 volvo s70 (76k miles) is defective but is not covered under warranty. i believe it should be covered for the life of the vehicle. i know many volvo owners have experienced this same problem. please instruct volvo to issue a recall to fix this crucial safety problem. *jb | |||
| 02/01/2003 | 1 | 03/01/2001 | |
| The abs light illuminated on the dashboard. *jb there is continuos failure of the abs braking system, and the consumer doesn't know if the system is engaged. the tracs control light is intermittent, and the consumer doesn't know if the wheels are going to lock not. *scc | |||
| 01/10/2003 | 85950 | 10 | 01/10/2003 |
| Abs / tracs lights come on due to defective abs controller. no anti-lock brakes. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 01/25/1999 | 25 | 06/15/1998 | |
| Electrical problems since shortly after purchase of vehicle, to dealer 25 times. dashboard light would come on, indicating that headlights were not working when in fact they were. *ak dealer stated vehicle had a bulb and socket problem, taillight bulb failed, signal lights flash very fast, side signals sockets and bulbs shorted, 4 running light contacts melted, front headlight shorted, left front headlight inoperable, and bulb indicator illuminated. door locks inoperable, windows would not go up, master window control switch faulty, and speakers distorted. seat belt plastic part cracked. transmission sticks on lowe gear, happened twice. gas light comes on even when tank is full. washer fluid inidcator illuminated, washer jets inoperable, wiper blads replaced, right side mirror did not adjust all the way out. front and rear brake pads worn, rotors replaced, brakes cause screeching noises. engine light illuminated, cable under engine loose. humming noise while driving, dealer replaced right front hub, left and right front stabilizer links. mudflaps loose. evap valve replaced. *slc | |||
| 07/04/1998 | |||
| Consumer has been expericing problems with brakes. when applying the brakes the steering starts to shake and the pedal virbrates. also, the driver's side window failed to go up.*ak | |||
| 08/02/1998 | |||
| While driving at 60 mph and applying the brakes there was very loud noise coming from the brakes, and everytime the consumer applied the brakes the noise was still coming from the brakes. consumer took the vehicle to the dealer,and the dealer rotated the tires and checked the brakes, and the problem is still there. *ak | |||
| 08/17/1997 | 08/05/1997 | ||
| Gas pedal lost responsiveness and suddenly accelerated. at the same time, brakes locked up. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
| 03/26/2001 | |||
| Vehicle would vibrate when applying brakes. dealer notified, and had front brake rotors and pads replaced on two separate occasions, but problem is stilloccurring. feel free to provide any further information.*ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
| 1 | 05/06/1999 | ||
| The left front brake rotor locked up, causing some components to burn up. *ak the problem was due to a stuck caliper, which according to volvo is not related to the brake pad and rotor replacement performed by dealer. lower ball joint was also replaced. *la | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||
| 04/01/2000 | 9 | ||
| During braking at slow speeds intermittently there is a loud pop. then, pedal goes to floor, resulting in extended stopping distance. vehicle taken to dealer 8-9 times. replaced brake pads twice, found lots of black dust, but stated that was normal. problem not remedied. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 1 | 06/01/1998 | ||
| With approximately 57,000 miles on the odometer i started experiencing severe vibrations when i applied the brakes stopping in a straight line and when turning left at speeds approximating 15-20 miles an hour. the dealer told me that the front rotors were warped because they are aluminum and warp if they get wet when they are hot. duh! this is florida, how can they not get hot & wet? the rear rotors were replaced at approx 30,000 miles.deel is currently replacing the rack & pinion steering assembly which apparently caused the severe vibrations when turning left & braking. this car has been maintained at deel volvo in accordance with the manufacturers guidelines.*ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - MASTER CYLINDER | |||
| 08/26/2003 | 74500 | 3 | 06/30/1998 |
| While braking, the vehicle vibrated. took vehicle to dealership and the mechanic indicated there was a crack in the brake master cylinder.*ak the abs light illuminated, the oxygen sensor was replaced, the vacuum line was replaced, the upper torque arm bushing broke, the door locking system broke, the inside door panel came apart. *jb *nm | |||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - VACUUM - HOSES, LINES/PIPING, AND FITTINGS | |||
| 08/16/1997 | 08/05/1997 | ||
| A piece of the vacuum brake system came loose, causing engine to increase its rpms spontaneously and locke dup the brakes, resulting in loss of control. *ak | |||