Workhorse W22 2000
Model W22 made in 2000 by Workhorse got 4 consumer complains there are 7 investigations as well as 1 recall. Consumer complaints with reference to service brakes, hydraulic. . The car had one investigation (service brakes, hydraulic). There was one recall concerning service brakes, hydraulic .
Model 2000
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC | ||||||||||||||||
04V084000 | WORKHORSE CUSTOM CHASSIS | from 08/10/2000 to 06/29/2002 | V (Vehicle) | 10235 | 08/01/2004 | ODI | WORKHORSE CUSTOM CHASSIS | 02/18/2004 | 03/03/2004 | |||||||
Defect Summary | On certain motorhome chassis equipped with bosch zops, the pads can drag on the rotor surface due to the pin slide. | |||||||||||||||
Consequence Summary | A hang up or lock up may cause the calipers to over heat and not allow the driver to stop safely. this could cause overheating of the brake calipers which could result in a vehicle fire. | |||||||||||||||
Corrective Summary | Dealers will inspect, repair and replace according to the procedure developed by bosch (see campaign 03e064000). the recall began on august 1, 2004. owners should contact workhorse at 1-877-294-6773. | |||||||||||||||
Notes | Workhorse recall no. 50401-c.customer's can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC | ||||||
EA07016 | WORKHORSE CUSTOM CHASSIS | 11/16/2007 | 08/19/2009 | OVERHEATING DISC BRAKE CALIPER | 09V217000 | |
The ea was opened to gain a technical understanding of the causes for one or more disc brake calipers on a subject vehicle to suffer severe overheating. the overheating caused brake drag, melting abs sensors, smoking, brake lining fires, and in some cases boiling brake fluid resulting in diminished stopping capability.based on testing, warranty and complaint data analysis, field trips and interviews with owners, mechanics and service managers, odi believes the likely cause of the alleged defect is water swell of the phenolic caliper piston and subsequent failure of the piston to fully return after the pedal is released.a technical report is attached with full details. | ||||||
EA07016 | WORKHORSE CUSTOM CHASSIS | 11/16/2007 | 08/19/2009 | OVERHEATING DISC BRAKE CALIPER | 09V206000 | |
The ea was opened to gain a technical understanding of the causes for one or more disc brake calipers on a subject vehicle to suffer severe overheating. the overheating caused brake drag, melting abs sensors, smoking, brake lining fires, and in some cases boiling brake fluid resulting in diminished stopping capability.based on testing, warranty and complaint data analysis, field trips and interviews with owners, mechanics and service managers, odi believes the likely cause of the alleged defect is water swell of the phenolic caliper piston and subsequent failure of the piston to fully return after the pedal is released.a technical report is attached with full details. | ||||||
EA07016 | WORKHORSE CUSTOM CHASSIS | 11/16/2007 | 08/19/2009 | OVERHEATING DISC BRAKE CALIPER | 09V193000 | |
The ea was opened to gain a technical understanding of the causes for one or more disc brake calipers on a subject vehicle to suffer severe overheating. the overheating caused brake drag, melting abs sensors, smoking, brake lining fires, and in some cases boiling brake fluid resulting in diminished stopping capability.based on testing, warranty and complaint data analysis, field trips and interviews with owners, mechanics and service managers, odi believes the likely cause of the alleged defect is water swell of the phenolic caliper piston and subsequent failure of the piston to fully return after the pedal is released.a technical report is attached with full details. | ||||||
EA07016 | WORKHORSE CUSTOM CHASSIS | 11/16/2007 | 08/19/2009 | OVERHEATING DISC BRAKE CALIPER | 09V110000 | |
The ea was opened to gain a technical understanding of the causes for one or more disc brake calipers on a subject vehicle to suffer severe overheating. the overheating caused brake drag, melting abs sensors, smoking, brake lining fires, and in some cases boiling brake fluid resulting in diminished stopping capability.based on testing, warranty and complaint data analysis, field trips and interviews with owners, mechanics and service managers, odi believes the likely cause of the alleged defect is water swell of the phenolic caliper piston and subsequent failure of the piston to fully return after the pedal is released.a technical report is attached with full details. | ||||||
EA07016 | WORKHORSE CUSTOM CHASSIS | 11/16/2007 | 08/19/2009 | OVERHEATING DISC BRAKE CALIPER | 09V186000 | |
The ea was opened to gain a technical understanding of the causes for one or more disc brake calipers on a subject vehicle to suffer severe overheating. the overheating caused brake drag, melting abs sensors, smoking, brake lining fires, and in some cases boiling brake fluid resulting in diminished stopping capability.based on testing, warranty and complaint data analysis, field trips and interviews with owners, mechanics and service managers, odi believes the likely cause of the alleged defect is water swell of the phenolic caliper piston and subsequent failure of the piston to fully return after the pedal is released.a technical report is attached with full details. | ||||||
EA07016 | WORKHORSE CUSTOM CHASSIS | 11/16/2007 | 08/19/2009 | OVERHEATING DISC BRAKE CALIPER | 09V204000 | |
The ea was opened to gain a technical understanding of the causes for one or more disc brake calipers on a subject vehicle to suffer severe overheating. the overheating caused brake drag, melting abs sensors, smoking, brake lining fires, and in some cases boiling brake fluid resulting in diminished stopping capability.based on testing, warranty and complaint data analysis, field trips and interviews with owners, mechanics and service managers, odi believes the likely cause of the alleged defect is water swell of the phenolic caliper piston and subsequent failure of the piston to fully return after the pedal is released.a technical report is attached with full details. | ||||||
EA07016 | WORKHORSE CUSTOM CHASSIS | 11/16/2007 | 08/19/2009 | OVERHEATING DISC BRAKE CALIPER | 09V198000 | |
The ea was opened to gain a technical understanding of the causes for one or more disc brake calipers on a subject vehicle to suffer severe overheating. the overheating caused brake drag, melting abs sensors, smoking, brake lining fires, and in some cases boiling brake fluid resulting in diminished stopping capability.based on testing, warranty and complaint data analysis, field trips and interviews with owners, mechanics and service managers, odi believes the likely cause of the alleged defect is water swell of the phenolic caliper piston and subsequent failure of the piston to fully return after the pedal is released.a technical report is attached with full details. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, HYDRAULIC | |||
09/15/2002 | 31000 | ||
Tl-the contact owns a 2000 workhorse w22. while driving at approximately 40 mph pressure was applied to the brake pedal and the steering wheel began to shake. the anti lock brake services light also began to illuminate on the dashboard. the vehicle was taken to an authorized dealer where he was informed the brake rotors were warped and the brake pads were worn down. the vehicle was not repaired and the failure continues to recur while applying the brakes at any speed. the failure and current mileages were 31,000. sm. | |||
04/15/2008 | 31252 | 1 | |
This compliant is the same as complaint # 50901-c. i requested that workhorse reimburse me for my expenses and i received a letter from them stating that my coach did not fall into the parameter of the campaign. this coach has the same braking system that is on the ones mentioned in the file # 50901-c. this is what i reported to workhorse on 10/26/2009 my wife and i were checking out camping areas in defuniak springs, fl approximately the first part of april 2008. driving down a small incline to the park i noticed that the brakes felt spongy and would not stop the motorhome no matter how much i pressed on the brakes. i pulled the parking brake and finally stopped before going into the lake. i reversed up the hill and drove until i could park and on level ground. upon checking the brake fluids i burnt my finger touching the brake fluid filler cap. after approximately 45 minutes i was able to remove the cap and most of the fluid had boiled out all over the wheel well on to the tire. i refilled the brake fluid and drove back to milton, fl real slow. on 4/17/08 i called carpenter's campers in pensacola, fl about the brake problem and they referred me to dave howell tires, inc. i drove to their shop for an inspection (inspection fee $35.00 invoice attached with others) and they said that the right front wheel rotor had crystallized and that they others had damage. after much negotiation (started at $3k plus) we settled upon the parts and labor performed on invoice attached in the amount of $1621.86. on the next trip out i had problems with the front tires. on july 29, 2008 and took the mh to bee-line in pensacola to have it checked out. they found the sway bar bushings gone, air bags nothing but rags and that the tires had damage from the brake fluid spilling all over the place. bee-line replaced sway bar bushings $119.00 on 07/29/08 . advanced tires replaced front tires $395.85 on 07/31/08. bee-line replaced air bags $499.88 on 08/01/08. *tr |