Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | ||||||||||||||||
| 12E029000 | Valeo | E (Equipment) | 585 | MFR | BMW OF NORTH AMERICA, LLC | 08/10/2012 | 08/14/2012 | |||||||||
| Defect Summary | Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 bmw 1-series, 2006-2011 bmw 3-series, 2000-2009 bmw 5-series, 2004-2005 bmw 6-series, and 2006-2007 bmw 7-series vehicles. a metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. this primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short. | |||||||||||||||
| Consequence Summary | This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment. | |||||||||||||||
| Corrective Summary | Valeo will notify owners and replace the fans free of charge. the safety recall is expected to begin during august 2012. this recall is being conducted by valeo, not by bmw. for further information, owners may contact valeo at 1-888-718-2536. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| SIB-12-16-07 | 03/01/2011 | 10040170 | Bmw: a software error is causing the the service engine soon light to come on. there will be stored trouble codes. *rm | 08/16/2011 | |
| SIB-12-16-07 | 03/01/2011 | 10040170 | Ready | 08/16/2011 | |
| SI B12 55 06 | 01/01/2011 | 10037700 | Ready | 06/03/2011 | |
| SI B12 11 10 | 01/01/2011 | 10037703 | Bmw: there are high fuel pressure faults stored due to a software error. *rm | 06/03/2011 | |
| SI B12 02 11 | 01/01/2011 | 10037704 | Bmw: on low mileage vehicles the engine runs rough, mifires, or fails to crank. this is caused by multiple short start-ups without the engine properly going through a warm-up phase. *rm | 06/03/2011 | |
| SI B12 55 06 | 01/01/2011 | 10037700 | Bmw: there may be excessive cranking before the vehicle starts. the service engine soon light may also be on with a lack of engine power. *rm | 06/03/2011 | |
| SI B12 02 11 | 01/01/2011 | 10037704 | Ready | 06/03/2011 | |
| SI B12 11 10 | 01/01/2011 | 10037703 | Ready | 06/03/2011 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| SIB-12-16-11 | 08/01/2011 | 10041407 | Ready | 09/30/2011 | |
| SIB-12-16-11 | 08/01/2011 | 10041407 | Bmw: service engine soon light is on and the engine has reduced power with trouble codes stored. *rm | 09/30/2011 | |
| TS-12-19-10 | 08/01/2010 | 10041276 | Bmw: service engine soon light is on with a fault code stored. internal dmtl pump failure.*rm | 09/26/2011 | |
| TS-12-19-10 | 08/01/2010 | 10041276 | Ready | 09/26/2011 | |
| SIB-12-15-11 | 07/01/2011 | 10040852 | Bmw: the service engine soon light is on. there are trouble codes stored for the crankshaft sensor. no driveability issues. *rm | 09/13/2011 | |
| SIB-12-15-11 | 07/01/2011 | 10040852 | Ready | 09/13/2011 | |
| SIB-17-05-10 | 05/01/2011 | 10039591 | Ready | 08/03/2011 | |
| SIB-17-05-10 | 05/01/2011 | 10039591 | Bmw: the service engine light is on with stored fault codes. there is a wiring/connection problem or a faulty sensor. *rm | 08/03/2011 | |
| SIB-12-21-10 | 09/01/2010 | 10037079 | Ready | 05/04/2011 | |
| SIB-12-21-10 | 09/01/2010 | 10037079 | Bmw: service engine soon light is on. the vehicle lost power and the engine cranks with no start. *rm | 05/04/2011 | |
| SIB-22-01-10 | 09/01/2010 | 10037072 | Bmw: there can be vibration in the engine while driving at various speeds due to engine mount bracket bolts. *rm | 05/02/2011 | |
| SIB-22-01-10 | 09/01/2010 | 10037072 | Ready | 05/02/2011 | |
| SIB-11-13-07 | 08/01/2010 | 10037052 | Bmw: bmw: there is a software error that is causing the service engine soon light to illuminate without a fault code. *rm | 04/29/2011 | |
| SIB-11-13-07 | 08/01/2010 | 10037052 | Ready | 04/29/2011 | |
| SIB-11-08-03 | 07/01/2010 | 10037010 | Bmw: six different models equipped with the m54 engine could have valve covers break in cold weather and ruin the engine. this is due to moisture accumulation. *rm | 04/27/2011 | |
| SIB-11-08-03 | 07/01/2010 | 10037010 | Ready | 04/27/2011 | |
| SIB-13-06-10 | 06/01/2010 | 10036985 | Ready | 04/25/2011 | |
| SIB-13-07-10 | 06/01/2010 | 10036982 | Bmw: there is a rough engine idle and service engine soon light when driving downhill in high altitudes during cold weather. there may be six different fault codes. *rm | 04/25/2011 | |
| SIB-13-06-10 | 06/01/2010 | 10036985 | Bmw: a service engine soon light comes on. the engine will only operate to 1500 rpms and lacks power. there is a software application error. *rm | 04/25/2011 | |
| SIB-13-07-10 | 06/01/2010 | 10036982 | Ready | 04/25/2011 | |
| SI-B12-22-10 | 10/01/2010 | 10035007 | Bmw vehicle: program control units. service engine soon (mil) lamp may come on due to a diagnostic error. to determine whether a specific vehicle has had this service completed or is affected by this service, first check the b pillar lab | 02/07/2011 | |
| SIB-11-14-07 | 11/01/2007 | 10032809 | Bmw vehicle: n54 turbocharger waste gate control noises and operation. after turning off engine, a slight rattle noise is heard from the engine compartment. this noise is similar to a mechanical typewriter. in addition, the complaints o | 05/26/2010 | |
| SIB-11-02-08 | 02/01/2008 | 10032779 | Bmw vehicle: the service engine soon (mil) lamp is illuminated and a power reduction is clearly perceptible. this situation may occur after driving for some time with the engine already at full operating temperature. if the ignition is c | 05/21/2010 | |
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
| SIB-17-05-10 | 05/01/2011 | 10039591 | Bmw: the service engine light is on with stored fault codes. there is a wiring/connection problem or a faulty sensor. *rm | 08/03/2011 | |
| SIB-17-05-10 | 05/01/2011 | 10039591 | Ready | 08/03/2011 | |
| SIB-16-03-10 | 06/01/2010 | 10036981 | Ready | 04/25/2011 | |
| SIB-11-02-10 | 06/01/2010 | 10036983 | Ready | 04/25/2011 | |
| SIB-11-02-10 | 06/01/2010 | 10036983 | Bmw: service engine soon light is on with diesel engines. *rm | 04/25/2011 | |
| SIB-16-03-10 | 06/01/2010 | 10036981 | Bmw: warning message on about low diesel exhaust fuel level and that the engine will not restart within 999 miles. the light comes on a few thousand miles earlier than a recommended oil change. *rm | 04/25/2011 | |
| SI-B12-22-10 | 10/01/2010 | 10035007 | Bmw vehicle: program control units. service engine soon (mil) lamp may come on due to a diagnostic error. to determine whether a specific vehicle has had this service completed or is affected by this service, first check the b pillar lab | 02/07/2011 | |
| SI-B-13-03-10 | 05/01/2010 | 10034189 | Bmw: program control units. vehicles with m57y diesel engine. service engine soon lamp (mil) is illuminated erroneously. dde software error. *pe | 10/25/2010 | |
| SIB-11-02-08 | 02/01/2008 | 10032779 | Bmw vehicle: the service engine soon (mil) lamp is illuminated and a power reduction is clearly perceptible. this situation may occur after driving for some time with the engine already at full operating temperature. if the ignition is c | 05/21/2010 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| SI-B12-22-10 | 10/01/2010 | 10035007 | Bmw vehicle: program control units. service engine soon (mil) lamp may come on due to a diagnostic error. to determine whether a specific vehicle has had this service completed or is affected by this service, first check the b pillar lab | 02/07/2011 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
| SIB-11-13-07 | 08/01/2010 | 10037657 | Ready | 06/01/2011 | |
| SIB-11-13-07 | 08/01/2010 | 10037657 | Bmw: there is a clanking noise from the engine or exhaust area. wastegate valve is not completely closing and clanking. *rm | 06/01/2011 | |
| SIB-11-14-07 | 11/01/2007 | 10032809 | Bmw vehicle: n54 turbocharger waste gate control noises and operation. after turning off engine, a slight rattle noise is heard from the engine compartment. this noise is similar to a mechanical typewriter. in addition, the complaints o | 05/26/2010 | |
| ENGINE AND ENGINE COOLING - ENGINE - OTHER FUEL TYPES - TURBO-CHARGER | |||||
| SIB-11-13-07 | 08/01/2010 | 10037657 | Ready | 06/01/2011 | |
| SIB-11-13-07 | 08/01/2010 | 10037657 | Bmw: there is a clanking noise from the engine or exhaust area. wastegate valve is not completely closing and clanking. *rm | 06/01/2011 | |
| SIB-11-14-07 | 11/01/2007 | 10032809 | Bmw vehicle: n54 turbocharger waste gate control noises and operation. after turning off engine, a slight rattle noise is heard from the engine compartment. this noise is similar to a mechanical typewriter. in addition, the complaints o | 05/26/2010 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| SIB-16-01-09 | 09/01/2010 | 10037076 | Ready | 05/04/2011 | |
| SIB-16-01-09 | 09/01/2010 | 10037076 | Bmw: there is an extraction and refilling process for the desiel exhaust fluid. e70 and e90 models. *rm | 05/04/2011 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| SIB-18-02-12 | 08/01/2012 | 10046861 | Bmw: see document search button for owner letter. the replacing and/or checking of emissions monitoring components to increase emissions stability, high pressure (hp) egr valve restriction of excessive soot and improved diesel exhaust f | 10/31/2012 | |
| SIB-01-02-12 | 07/01/2012 | 10045279 | Bmw: a failure of the turbocharger wastegates, caused by a defect, has an emissions extended warranty, 8 years or 82,000 miles, whichever comes first, not otherwise falling within coverage exclusion. *pe | 08/27/2012 | |
| SIB-13-13-10 | 09/01/2011 | 10042684 | Bmw: on some vehicles, the high pressure fuel pump has an internal component that may fail and causing drivability symptoms such as erratic engine operation and longer starting times. *pe | 01/06/2012 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
| SIB-11-03-08 | 12/01/2010 | 10038217 | Bmw: crankcase pressure diagnosis and information for all vehicles. *rm | 06/10/2011 | |
| SIB-11-03-08 | 12/01/2010 | 10038217 | Ready | 06/10/2011 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
| SIB-18-02-12 | 08/01/2012 | 10046861 | Bmw: see document search button for owner letter. the replacing and/or checking of emissions monitoring components to increase emissions stability, high pressure (hp) egr valve restriction of excessive soot and improved diesel exhaust f | 10/31/2012 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 08/18/2011 | 38000 | 1 | |
| On thursday, august 18, 2011, my 2009 328i shut down without notice in the middle lane of i-90 at mile marker 80.002 about a mile from ohare airport in chicago. it was unable to restart and i was left to call 911 and spend 10 minutes waiting for dot to tow me off the middle of the highway and to a residential neighborhood to wait another hour for aaa to tow my car to perillo bmw in chicago to assess the issue. june 15th 2011: about 3 hours after bringing my car into the zimbrick bmw service facility to have a set of after-market led lights installed at cost, the service engine soon light appeared illuminated on my dashboard. as i had never seen this light appear on my less than 2 year old car before, i immediately called the person who was head of your service department to discuss how this light could appear for the first time after having my car in hours earlier on a service appointment that should not have touched the engine. a loaner car was promptly driven to my office, to check into the issue and take my car back to the dealership for further inspection, if necessary. the following is the conversation that transpired between the service rep and i, upon his review of my vehicle, using a computer connection to pull data from my cars onboard computer system: sa: when was the last time you filled the car with gas? me: (checking the odometer, as i reset it with each full tank of gas) about 97 miles ago. sa: well, the computer is reporting the issue has something to do with your fuel pump, however, i think it might just be that your gas cap may have been unscrewed. me: i can't say that makes much sense, as i filled it up 97 miles ago and haven't seen an issue until now. sa; well, let me just turn the indicator light off and let me know if you run into this issue again. | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 06/02/2011 | 35000 | ||
| Engine will shut off when clutch is depressed. this situation happens when exiting the highway on hot days with the ac running. it has happened multiple times under the same scenario. | |||