Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 070397 | 05/09/1997 | 07-05-93 | 6088786 | Concerns with engine coolant usage. *nlm | 01/07/2000 |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 0700202 | 02/04/2002 | 070200 | 629133 | Subject regarding low or no cabin head, engine cooling system system fill procedure. *tt | 03/27/2002 |
| 070200 | 06/16/2000 | 614154 | Some vehicles may exhibit engine overheating and / or coolant bottle failures after service has been performed on the engine cooling system. *tt | 09/29/2000 | |
| 070397 | 05/09/1997 | 52963 | Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of ethylene glycol. *yc | 11/13/1997 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 0900801 | 11/02/2001 | 632197 | Subject regarding camshaft / bearing service. *tt | 07/11/2002 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 090193 | 05/01/1993 | 39540 | Oil smoke in exhaust. *tw | 11/01/1995 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 36800 | 3 | ||
| While driving at 25 mph vehicle stalled, then the engine light came on. dealership replaced the camp shaft sensor. vehicle stalled again within 330 miles. then, engine light came on. vehicle wouldn't restart. in attempt to correct the problem dealership replaced the computer/ fuel pump, but the vehicle wouldn't start. dealership was about to replace the timing belt when they noticed black sludge all over the engine compartment. dealership indicated that the engine was slipping time. *ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 07/01/1999 | 2 | 11/01/1994 | |
| First the headlight lenses clouded over; had to be replaced. then the injector shot fuel on the engine, car caught fire; $3600 in damage. then the rearview mirror fell off thrice; bought a new one. the car constantly runs hot since last year; replaced cooling block; now it only runs hot when idling or in stop-n-go traffic; have to run the heater to keep it from overheating; mechanic cant find the cause; ac temp changes from cool to tepid when car idles at a traffic light; once car begins to move, air retuns to cool. the overhead computer just quit, as well as the electronic climate control unit(ecu); ecu replaced. when outside temp drops around freezing car has a banging noise underneath, until it warms up. remote door locks quit working within 2 years of ownership. | |||
| 05/05/1996 | 3 | ||
| While driving vehicle, it would stall out without any warning. was not able to restart vehicle. had it towed to dealer. mechanic indicated the problem was broken water pump. water pump was replaced in 1996, & currently its 2000, and same stalling problem has reappeared. *ak | |||
| 05/13/1998 | 1 | ||
| Water pump failed. nlm | |||
| 11/06/1998 | 1 | 03/31/1998 | |
| Water pump failed prematurely. | |||
| 02/01/1998 | |||
| Power brake booster/turn signal/hazard lights/horn/ automatic door locks and water pump failed @ 36,000 while stopping on highway in 65mph traffic. problems still exists. dealer would not fix it since vehicle was out of warranty. provide further information. *ak | |||
| 09/20/1998 | 1 | ||
| Water pump failed. | |||
| 11/21/1996 | 1 | 12/01/1992 | |
| Fuel injection: fuel rail leaks, spills gasoline on top of engine, could cause a fire. *ak consumer sttes there have been other product defects such as the transmission, water pump, timing belt, door lock and trunk lock and the rear view mirror consumer states some were covered by warranty. *jb | |||
| 4 | |||
| Abs main power relay failed, also replaced power steering rack/water pump/windshield wiper motor/left sway bar. *ak | |||
| 09/11/1996 | 5 | ||
| Abs main power relay failed, also replaced steering rack/left sway bar/water pump/windshield wiper. *ak | |||
| 1 | 06/01/1994 | ||
| Purchased car used, the front caliper had to be replaced . *ak tie rod bolt to front left wheel fell out, steering inoperable. brakes began vibrating at 23000 miles, when braking brakes sounded like metal on metal, brake shoe on the front left was completely gone and rusted. water pump failed and was replaced. *slc | |||
| 04/19/1996 | 9 | ||
| Water pump replaced. *sd | |||
| 10/31/1995 | |||
| Estimated speed 60 mph when water pump seized up causing timing chain to break coasting to side of road. please describe details. tt | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||
| 07/13/1998 | 1 | ||
| Fan motor failed causing overheating. nlm | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
| 03/25/2002 | 0 | ||
| Consumer had to replace radiator and thermostat. vehicle kept overheating. *ak | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 05/05/1996 | 3 | ||
| While driving vehicle, it would stall out without any warning. was not able to restart vehicle. had it towed to dealer. mechanic indicated the problem was broken water pump. water pump was replaced in 1996, & currently its 2000, and same stalling problem has reappeared. *ak | |||
| 01/08/2000 | 1 | ||
| Both motor mounts and transmission mounts failed. nlm | |||
| 05/13/1998 | 1 | ||
| Timing belt and tensioner pulley failed. nlm | |||
| Recall # 99v215000 engine: other parts: owner made an appointment for march 7, 2000. after arriving at dealership, owner was informed that parts(s) were not available. owner was not able to schedule another appointment because dealer did not know if parts will be available. owner was told to call back in 3 weeks. please provide any further information. *ak | |||
| 06/15/1997 | 12 | 06/01/1993 | |
| At low speed 20mph in parking lots or heavy traffic with a/c on all gauges the instrument on panel would go off immediately and the heater comes on blowing at full speed. took the vehicle to dealer no warranty for electrical problems. they said vehicle needed a new ignition switch. replaced at consumer cost. also while driving on highway abs light came on and stayed on, and the wheels locked up at heavy braking. dealer's response no warranty, diagnosis showed it needed new computer. 3 months later, abs came on intermittently. dealer said it needed abs brake relay, emercency brake inoperative (1993), evaporator core ruptured, head gasket warped from overheating causing leakage. *ak | |||
| 05/22/1996 | |||
| Vehicle experiencing ongoing problem with ball joint and inner tie rod. parts have been replaced on two occasions; once at 52,000 miles of wear, and another at 94,000 miles of wear. also, engine head gasket blew out in late december, 1998. dealer notified. repairs and parts were charged to consumer. *ak | |||
| 12/08/1997 | 1 | 03/01/1995 | |
| The helena chrysler dealership made all repairs to the fuel rail. there was a fuel leak from the fuel rail--the fuel rail was replaced as well as o rings and gaskets. i did contact the chrysler corp. however they said they were unable to help me and refused to comment on the extreme safety issue. and at the time of the phone call april, 1998 i had to take my car back to the dealership and have the same 'o' rings and gaskets replaced because the intake manifold gaskets failed. i called to find out if there had been any recalls for my car and if any were associated with the fuel rail. at that time there wasn't a recall. i would appreciate any help you can provide and if i can be refunded any money for repairs that would be great!! | |||
| 07/30/1997 | 09/30/1997 | ||
| Intermittent stalling due to crankshaft failure. *ak | |||
| 11/21/1996 | 1 | 12/01/1992 | |
| Fuel injection: fuel rail leaks, spills gasoline on top of engine, could cause a fire. *ak consumer sttes there have been other product defects such as the transmission, water pump, timing belt, door lock and trunk lock and the rear view mirror consumer states some were covered by warranty. *jb | |||
| 10/31/1995 | |||
| Estimated speed 60 mph when water pump seized up causing timing chain to break coasting to side of road. please describe details. tt | |||
| 06/05/1995 | 1 | ||
| Tension pulley broke, causing drive belt to snap and engine to stop. *ak | |||
| 11/30/1994 | 1 | ||
| Timing belt gasket replaced to stop oil leak. tt | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 04/15/2001 | 4 | 05/01/1993 | |
| Vehicle stalls at any speed/any time. took vehicle to mechanic 4 times, cannot find problem. *ak | |||
| 03/18/2000 | 1 | ||
| Bolts are in the oil pan that loose, vehicles needs front cover and front seal. *mjs | |||
| 1 | |||
| Possible engine failure resulted in the vehicle stalling at stops. | |||
| 04/01/1999 | 10 | 03/01/1997 | |
| This recall is a windfall in repairs for the dealer. everything is now failing because of the age of the car ( from the service manager). i have spoken to other owners of the same car and they are having the same problem................ | |||
| 03/01/1997 | |||
| While driving the vehicle will stall without any warning which almost resulted in an accident. sometimes the vehicle will start after the incident. also, had the same problems with the 1993 dodge intrepid which the consumer traded for the 1993 concorde. *ak | |||
| 05/16/1998 | 1 | ||
| Engine fire (ohio state police). | |||
| 04/16/1997 | |||
| Engine failed to operate properly.it made a clunking sound and stalled. also replaced transmission and ignition. | |||
| 10/17/1997 | |||
| While vehcle was parked it caught on fire in the engine compartment. the fire totalled the vehicle. *ak | |||
| 07/16/1997 | 09/30/1993 | ||
| Engine stops for unknown reason. | |||
| 05/31/1996 | |||
| Drove vehicle 1/2 mile from home, driver noticed smoke coming from hood, pulled over & turned off engine, vehicle front was on fire within a few minutes. *ak | |||
| 10/16/1995 | 4 | 07/01/1993 | |
| Throttle body is not getting enough air, causing loss of power steering, engine stalls. tt *jb | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
| 05/13/1998 | 1 | ||
| Timing belt and tensioner pulley failed. nlm | |||
| 04/19/1996 | 9 | ||
| Serpentine belt replaced. *sd | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 01/01/1998 | |||
| When driving there was a gas leakage, and the gas smell was strong. when the consumer opened up the hood, the gas smell was strong and there were other leakages. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 1 | |||
| Coil pack failed. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
| 10/11/1998 | 1 | ||
| Filter for the catalytic converter broke apart and clogged the catalytic converters causing overheating of the converters which melted the egr valve and fused joints of the exhaust manifold pipe. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||
| 1 | 04/01/1993 | ||
| Egr valve failed, intake manifold gasket failed. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 1 | 04/01/1993 | ||
| Egr valve failed, intake manifold gasket failed. | |||