Gillig Low Floor 2007

Model Low Floor made in 2007 by Gillig got 5 recalls as well as 1 service bulletin. Technical service bulletines regarding structure. There were some recalls concerningengine and engine cooling and interior lighting.

Model 2007

Recalls

CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
ENGINE AND ENGINE COOLING
07V265000GILLIG CORPORATION V (Vehicle)207/31/2007MFRGILLIG CORPORATION06/08/200706/25/2007
Defect SummaryOn certain transit buses built with cummins ism c876 engines, the electronic control module fails to recognize inputs of the vehicle electronic control unit or from a driver actuated dash switch thereby increasing the risk of unintended (or unexpected) elevated exhaust temperatures.
Consequence SummaryWhile this condition does not involve a risk of fire in the vehicle itself, it could present a fire hazard in a situation where the vehicle's exhaust is in close proximity to materials or substances that can melt, burn, or explode.
Corrective SummaryCummins, in conjunction with gillig, will conduct the remedy campaign. the recall began on july 31, 2007. owners can contact cummins at 1-800-343-7357 or gillig at 1-510-785-1500.
NotesCustomers may also contact the national highway traffic safety administration
INTERIOR LIGHTING
09V368000GILLIG CORPORATIONfrom 01/01/2001 to 09/24/2009V (Vehicle)105309/29/2009MFRGILLIG CORPORATION09/28/200909/28/2009
Defect SummaryGillig corporation is recalling certain model year 2001 through 2009 transit buses manufactured between january 2001 and september 2009 equipped with luminator horizon led side destination signs. the connector board can corrode due to an accumulation of moisture under the connector.
Consequence SummaryA short could occur, possibly causing smoke and fire.
Corrective SummaryGillig will notify owners and luminator will repair the buses free of charge. the safety recall began on spetember 29, 2009. owners may contact luminator at 1-972-516-3033 or gillig field services at 1-800-735-1500.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
SERVICE BRAKES, AIR
08V008000GILLIG CORPORATIONfrom 07/10/2006 to 05/21/2007V (Vehicle)24901/29/2008ODIGILLIG CORPORATION01/09/200801/09/2008
Defect SummaryOn certain transit buses equipped with graham-white air dryers, the air dryer timer modules may allow sufficient quantities of moisture to enter and affect the operation of the vehicle air brake system.
Consequence SummaryFailure of the air brake system due to moisture could result in a crash.
Corrective SummaryGillig, in conjunction with graham-white, will replace the air dryer timer module on the affected vehicles. the recall began on january 29, 2008. owners may contact gillig at 1-510-785-1500 or graham-white at 540-387-5620.
NotesCustomers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS
07V259000GILLIG CORPORATIONfrom 03/01/2007 to 05/29/2007V (Vehicle)29106/27/2007MFRGILLIG CORPORATION06/07/200706/25/2007
Defect SummaryOn certain transit buses, the hydraulic hose located in the engine compartment was manufactured incorrectly which could cause a hydraulic fluid leak.
Consequence SummaryHydraulic fluid leakage could lead to a loss of fluid which could affect vehicle steering or create the conditions for a potential engine compartment fire.
Corrective SummaryGillig will provide correct hoses to their customers for replacement or will replace the hoses for them. the recall began on june 27, 2007. owners may contact gillig at 1-510-785-1500.
NotesCustomers may also contact the national highway traffic safety administration
SUSPENSION
08V175000GILLIG CORPORATIONfrom 09/20/2007 to 12/19/2007V (Vehicle)3104/29/2008MFRGILLIG CORPORATION04/16/200804/16/2008
Defect SummaryGillig is recalling 31 my 2007 29 foot low floor transit buses equipped with saf- holland adl series rear suspensions. in some instances the transverse beam was not properly welded which could result in a failure of the weld.
Consequence SummaryIf the weld fails, vehicle stability while cornering could be affected resulting in loss of vehicle control, possibly resulting in a crash. in addition, the transverse beam could drop to the ground causing sparks that could cause a fire hazard.
Corrective SummaryGillig is working with saf holland to have a visual inspection of the adl transverse beam performed. if a weld defect is identified, saf holland will provide a service replacement kit that contains a new transverse beam, all necessary installation hardware, beam replacement and instructions free of charge (please see 08e031). the recall began on april 29, 2008. owners may contact gillig at 1-510-264-5031 or saf-holland at 1-231-773-3271.
NotesCustomers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

Bulletins

BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
STRUCTURE - BODY
FS-2012-0201/13/201210044128Gillig: gillig's recommendations for the underbody maintenance can be found in chapter 11 of your service manual. *js05/14/2012

Some parts © 2026 Advameg, Inc.
Based on public records. Inadvertent errors are possible.
This web site is not associated with, endorsed by, or sponsored by and has no official or unofficial affiliation with the vehicle's manufacturer.