Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| PIP-4568K | 01/01/2011 | 10037941 | Ready | 06/08/2011 | |
| PIP-4568K | 01/01/2011 | 10037941 | Gm: service engine soon light is on with a misfire and a possible tick noise. *rm | 06/08/2011 | |
| PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
| PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 3908 | 10020490 | Full size utilities with coolant loss, rough running, and misfire. equipped with lmg lyd or lc0 5.3l engines. *kb | 10/27/2006 | ||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE | |||||
| 08-04-19-004 | 08/01/2008 | 10026624 | Gmc: correct front axle vent hose routing. the front axle vent hose is mounted in the left side of the engine compartment, and may not be correctly routed. *pe | 11/19/2008 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| PIT-4769B | 03/01/2011 | 10038624 | Gm: the air bag light is on with a stored trouble code. *rm | 06/24/2011 | |
| PIT-4769B | 03/01/2011 | 10038624 | Ready | 06/24/2011 | |
| PIP-3783C | 12/01/2010 | 10037809 | Ready | 06/06/2011 | |
| PIP-3783C | 12/01/2010 | 10037809 | Gm: the engine light is on and the vehicle lacks power. there are multiple possible trouble codes. *rm | 06/06/2011 | |
| PIP-4851 | 12/01/2010 | PIP-4851A | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm updated 5/31/11. *pe | 05/24/2011 |
| PIP-4851 | 11/01/2010 | 10037492 | Ready | 05/24/2011 | |
| PIP-4851 | 11/01/2010 | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm | 05/24/2011 | |
| SB-07-06-03-002C | 07/01/2010 | 10036524 | Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe | 03/28/2011 | |
| PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
| PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
| PIT-5028 | 09/01/2010 | 10036324 | Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. model years 2006-2011. does not apply to vehicles with keyless access system. *pe | 03/14/2011 | |
| SB-10-06-01-008 | 09/01/2010 | 10035804 | Cadillac/chevrolet/gmc/pontiac: engine oil consumption on aluminum block engines with active fuel management (afm) (install afm oil deflector and clean carbon from cylinder). caused by an uncovered afm valve that sprays oil on the bottom o | 03/04/2011 | |
| SB-09-06-01-006 | 05/01/2009 | 10030724 | Gmc/cadillac/chevrolet: check engine light on, engine misfire, hard start, rough idle, hesitation, loss of power, poor performance, noise, dtcs p0300, p0301, p0302,p0303, p0304, p0305, p0306, p0307, p0308 set (replace engine). *pe | 11/23/2009 | |
| PIT-4846A | 05/06/2009 | 10030244 | Cadillac/chevrolet/gmc: locations of high speed gmlan wiring concerns. gauges inoperative, no crank, harsh transmission shifting, no transmission shifting, door locks cycling and indicators on. *pe | 09/02/2009 | |
| SB-07-06-04-019A | 11/01/2008 | 10028831 | General motors: intermittent mil/ses/ dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-08 gm passengers cars/light duty trucks (incl. saturns). *pe | 06/01/2009 | |
| 08-06-04-012B | 11/19/2008 | 10026627 | Gmc: ei08047-intermittent mil/ses, dtc(s) p2120, 02122, 02123, 02125, p2127, p2128, p2138 with reduced engine power (replace accelerator pedal). this may be caused by corrosion at the accelerator pedal connector. *pe | 11/19/2008 | |
| 08-06-03-007 | 07/01/2008 | 10026007 | Gmc: no start, no crank, intermittent electrical operations (check for poor connections within engine wiring harness junction block). *pe | 09/23/2008 | |
| 08-07-30-021 | 05/01/2008 | 10025668 | Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, u0121, u0140 set (repair backed out terminal in transmission | 08/28/2008 | |
| 08-07-30-021 | 04/01/2008 | 10025402 | Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, 70140 (repair backed out terminal in transmission harness co | 08/06/2008 | |
| 08-06-04-012 | 03/01/2008 | 080604012A | 10024742 | Ei08047 - intermittent mil/ses, dtc's p2120, p2122, p2123, p2125, p2127, p2128, p2138 with reduced engine power. *nj | 05/15/2008 |
| PIP4321 | 02/01/2008 | PIP4321A | 10024285 | Oil leak at rear of engine. equipped with a 4.8, 5.3, 6.0 or 6.2 v8 engine. *nj | 04/01/2008 |
| PIT4284 | 02/01/2008 | PIT4284A | 10024282 | Engine stalls after being remote started. *nj | 04/01/2008 |
| PIP4344 | 02/01/2008 | 10024204 | Short duration cold start lifter tick noise. equipped with the 5.3 or 6.0 active fuel management engines. *nj | 03/24/2008 | |
| 3917 | 12/01/2007 | 3917E | 10022901 | Engine has low power on acceleration or when towing. equipped with the 6.0l ly6 and l76 engine. *nj updated 1/29/08. *nj | 10/03/2007 |
| 070604013 | 05/01/2007 | 10021841 | Chuggle, surge or hesitation may be felt with active fuel management system cylinder deactivation transition from v8 mode to v4 mode. *kb | 06/22/2007 | |
| 060603013 | 09/01/2007 | 060603013B | 10021448 | Intermittent low battery voltage, engine will not crank, engine cranks but will not start, charging system light on, service battery charging system message displayed, dtc b1405 and/or b1516 set. (reprogram bcm). *kb updated 11/02 | 04/27/2007 |
| 4040 | 4040A | 10021394 | Harsh tcc apply or tcc cycling. *kb | 04/24/2007 | |
| 060603011 | 01/01/2007 | 060603011A | 10021118 | Humming or buzzing from rear of vehicle and/or possible dead battery. (check fuel pump relay and replace, if necessary). *kb | 03/07/2007 |
| 4006 | 10021023 | Whine howl noise from the rear differential on vehicles equipped with an 8.6 rear axle. *kb | 02/22/2007 | ||
| 3939 | 10/05/2006 | 10020965 | Transfer case control module investigation. *kb | 02/02/2007 | |
| 3950 | 3950C | 10020968 | Intermittent service 4 wheel drive lamp on and code c0378. *kb updated 10/03/07. *nj | 02/02/2007 | |
| 060602007 | 05/01/2006 | 10020955 | Ly2, ly5, ly6, lh6, l76, lmg, lc9, l92, coolant or rubber type odor, loss of engine coolant and/or overheat condition. *kb | 02/01/2007 | |
| 060603009 | 10/01/2006 | 10020948 | Diagnostic information on battery draw no start - body control module, bcm power timer. *kb | 02/01/2007 | |
| 3845 | 10/12/2006 | 3845C | 10020926 | Malfunction indicator light (mil) illuminated diagnostic trouble code (dtc) p1825 and/or p1915. in the tcm no prndl display no crank. *kb | 01/30/2007 |
| 3996 | 10020911 | No movement or slipping or binding in forward range, mil illuminated, dtc p0777 or p2723. *kb | 01/29/2007 | ||
| 060845007 | 09/01/2006 | 10020889 | No start/loss of low speed lan, dtc's set. *kb | 01/26/2007 | |
| 060604042 | 09/01/2006 | 060604042A | 10020880 | Lr4, ly2, l33, lh6, lm7, l59, lc9, lmg, ly5, ls2, lq9, lq4, l76, ly6 throttle actuator control (tac). module codes, mil/ses dtc's p2108, p1516, u0107, reduced engine power. *kb | 01/25/2007 |
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
| PIP-4574M | 08/01/2010 | 10036485 | Buick/chevrolet/gmc/pontiac/saab: excessive oil consumption and/or blue exhaust smoke-investigation update. in most cases did not start until the engine accumulated approximately 30,000 miles or more. *pe | 03/21/2011 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| PIP-4574M | 08/01/2010 | 10036485 | Buick/chevrolet/gmc/pontiac/saab: excessive oil consumption and/or blue exhaust smoke-investigation update. in most cases did not start until the engine accumulated approximately 30,000 miles or more. *pe | 03/21/2011 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
| PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
| PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
| PIP3343 | 02/01/2008 | PIP3343A | 10024344 | Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj | 04/07/2008 |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| ENGINE AND ENGINE COOLING - ENGINE | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 08/10/2006 | 5168 | ||
| Vehicle gets extremely low gas, 13 mpg on average. burns oil . need to add 2-3 quarts of oil between oil changes. engine cooling fan stays on for extended periods while driving. all of which the dealership says is normal for the truck. they removed the driveshaft because of clunking at 25k mi. reaction carrier replaced and transmission reconditioned at 36,663 mi after car stopped in the middle of the street. car had to be towed in. at 62k miles engine light on and idles rough. replaced throttle body. at 67k won't engage in reverse and makes klunking sound from reverse to drive. replaced reverse housing, reaction shell, etc. at 75k had a reaction carrier failure, lost power brakes and lost power to the car. almost was rear ended. had to stop in middle of parking lot during christmas rush. waited 5 min and restarted. engine light stayed on, but was able to get to dealership. was told that throttle body needs to be cleaned every 15k miles under service maintence. this was the first time i heard this! not really sure why it had to be cleaned, though, just had the throttle body replaced 13k miles ago. it seems that there are major flaws in the design of the engine. obviously, the dealership has been putting band aids on my problem because they don't know how to fix. i have been very lucky that my family and children have not been in a major accident due to the major flaws in the engine designs. every time i get my car fixed, the tech assures me that they have fixed the problem. i am really afraid to drive this car with so many close calls. the car is a hazard to drive! | |||
| 09/24/2011 | 102000 | ||
| I was driving the vehicle down the road doing 65 mph. the engine light came on and the message appeared that stated engine power reduced service stablitract traction control off. the car lost all power and i was unable to go over 20 mph the rest of my trip home. i went from 65 mph to 20 mph in seconds, on the interstate full of traffic. when i got home i then noticed a hot smell. i then had the car towed to a mechanic. | |||
| 02/08/2007 | 12686 | 1 | |
| The cooling fan is very loud and stays on for an abnormal amount of time when the car is in park or at a stop while on only when the temperature outside is over 85 degrees. the fan will continue to stay on while driving for 10 to 15 minutes. sometimes it won't shut off until the car is shut off and then restarted. had it for repair on several different occasions at gmc and the technician said that is was normal. *tr | |||
| 03/21/2008 | 22000 | 1 | 01/20/2007 |
| Tl*the contact owns a 2007 gmc yukon. while parked in the driveway, the vehicle caught fire underneath the hood. the fire spread across the vehicle and caused an explosion, which burned down an entire home. the incident occurred at 5 am. the police and fire departments arrived on the scene and reports were filed. the vin was unknown. the current and failure mileages were approximately 22,000. updated 04-08-08 *bf updated 04/08/08 *tr | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 11/12/2010 | 76187 | ||
| Tl - the contact owns a 2007 gmc yukon. the contact stated that while driving 55 mph the check engine light illuminated and a message come on the dash board saying engine reducing power. also, the vehicle completely loosed power and was unable to steer to the side of the road. the vehicle was taken into the dealerships for the same failure three times and the vehicle is not repaired. the manufacturer advised to replaced the auto body assembly in order to remedy the problem. the failure mileage was 76187 and the current 77,600. pm | |||