Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||||||||||||
| 08V441000 | GENERAL MOTORS CORP. | from 09/30/2005 to 07/31/2007 | V (Vehicle) | 857735 | 09/12/2008 | ODI | GENERAL MOTORS CORP. | 08/28/2008 | 08/28/2008 | |||||||
| Defect Summary | Gm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. a short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire. | |||||||||||||||
| Consequence Summary | This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire. | |||||||||||||||
| Corrective Summary | Dealers will install a wire harness with an in-line fuse free of charge. the recall began on september 12, 2008. owners may contact buick at 1-866-608-8080; cadillac at 1-800-982-2339 or http://www.cadillac.com; chevrolet at 1-800-630-2438; saturn at 1-800-972-8876 or http://www.saturn.com, gmc at 1-866-996-9436; or hummer at 1-800-732-5493; or through their website at http://www.gmownercenter.com . | |||||||||||||||
| Notes | Gm recall no. 08048. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 10V240000 | GENERAL MOTORS CORP. | V (Vehicle) | 1365070 | 06/11/2010 | MFR | GENERAL MOTORS CORP. | 06/04/2010 | 06/04/2010 | ||||||||
| Defect Summary | Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). a recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. however, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. these incidents resulted from a new failure mode attributed to the device's thermal protection feature. the significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber. | |||||||||||||||
| Consequence Summary | It is possible for the heated washer module to ignite and a fire may occur. | |||||||||||||||
| Corrective Summary | Dealers will permanently disable and remove the heated washer fluid module. an updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. the safety recall is expected to begin on or before june 11, 2010. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| PIT-5184 | 10/01/2012 | 10047839 | Cadillac/chevrolet/gmc: will have inoperative cruise control; inoperative or unwanted activation of radio controls; backlighting flashes, flickers or inoperative due to possible short to ground on steering wheel coil connector x2. models | 12/10/2012 | |
| PB-10037A | 04/01/2011 | 10038759 | Ready | 06/27/2011 | |
| PB-10037A | 04/01/2011 | 10038759 | Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm | 06/27/2011 | |
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| PIT-4816A | 08/01/2009 | 10032396 | Chevrolet/gmc/cadillac: multiple electrical concerns with dtc c0900 - keywords battery c/k cable clock crank cycle door dimming flicker gage gauge gmc hvac inop inoperative instrument intermittent ipc lock no panel power radio stall start | 03/15/2010 | |
| SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
| PIT-4665A | 11/01/2008 | 10028264 | General motors: during normal diagnostics and/or repair verification the abs light, traction control and/or stabilitrak indicators may be on with no dtc's displayed by the ebcm. *pe | 03/19/2009 | |
| ELECTRICAL SYSTEM - BATTERY | |||||
| SB-07-06-03-002C | 07/01/2010 | 10036524 | Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe | 03/28/2011 | |
| PIC-4872 | 06/01/2009 | 10032866 | Gmc/chevrolet/cadillac: sir mil on with dtc b1325 sym 03. during a low battery/voltage condition the passenger presence system may set a b1325 sym 03 along with other faults that are caused by the low batter/voltage condition. *pe | 06/04/2010 | |
| PIT-4613A | 06/01/2008 | 10026697 | Gmc: intermittent no crank and/or discharged battery. could be caused by a loose connection at the 175 amp mega fuse located on the passenger side of the cowl. *pe | 12/03/2008 | |
| ELECTRICAL SYSTEM - BATTERY - CABLES | |||||
| SB-07-06-03-002C | 07/01/2010 | 10036524 | Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe | 03/28/2011 | |
| PIT-4613A | 06/01/2008 | 10026697 | Gmc: intermittent no crank and/or discharged battery. could be caused by a loose connection at the 175 amp mega fuse located on the passenger side of the cowl. *pe | 12/03/2008 | |
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||||
| PI0639A | 03/01/2012 | 10043887 | Gm: the service stabilitrak message being displayed in dic. the stabilitrak indicator light may also be on. *js | 05/01/2012 | |
| PIT-4613A | 06/01/2008 | 10026697 | Gmc: intermittent no crank and/or discharged battery. could be caused by a loose connection at the 175 amp mega fuse located on the passenger side of the cowl. *pe | 12/03/2008 | |
| ELECTRICAL SYSTEM - SOFTWARE | |||||
| PIT-4665A | 11/01/2008 | 10028264 | General motors: during normal diagnostics and/or repair verification the abs light, traction control and/or stabilitrak indicators may be on with no dtc's displayed by the ebcm. *pe | 03/19/2009 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 08/16/2011 | 120000 | ||
| Tl-the contact owns a 2007 gmc yukon xl. the contact stated that the lights for the instrument panel would no longer illuminate. as a result, the contact was not able to read any of the gauges except for the speedometer. the vehicle was not taken to have the failure diagnosed or repaired. the manufacturer was made aware of the failure but provided no further assistance. the approximate failure mileage was 120,000. kmj | |||
| 08/16/2011 | 120000 | ||
| Tl-the contact owns a 2007 gmc yukon xl. the contact stated that the lights for the instrument panel no longer illuminated. as a result, the contact was not able to read any of the gauges except for the speedometer. the vehicle was not taken to have the failure diagnosed or repaired. the manufacturer was made aware of the failure and referred the contact to nhtsa. the approximate failure mileage was 120,000. sm. | |||