Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||||
| 2401201 | 09/14/2001 | 625576 | Customers may complain that the hvac drain water leaks under passenger side carpet. *tt | 11/29/2001 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| VISIBILITY | |||
| 08/20/2009 | 44203 | 1 | |
| There is a serious product defect in the fan motor-switch-resister assembly in my 2001 jeep wrangler. this condition has been repaired seven times, six times unsuccessfully (the first time was in 2004, the year i bought my jeep from a dealership) and the last one accomplished august 20, 2009 and who knows how long this will last. the problem is that the fan switch suddenly fails to operate and when the matter is investigated the mechanic finds that the blower motor, relay and switch have melted. there is some sort of electrical problem or surge which six repairs have failed to correct and my fear is my jeep will catch on fire as has been reported in a number of cases. *tr | |||
| 05/19/2009 | 1 | ||
| Driving 2001 jeep wrangler with bestop slider windows, installed above factory half doors. upper door slider for tj wrangler part number 51787. *tr plastic tabs on window unit all of a sudden broke and window flew into driver's head and face. bestop in broomfield colorado800 845 3561 refused to replace or repair product and refused to comment on failure or safety. | |||
| 10/01/2007 | 95000 | 1 | |
| Failure of heating system (extremely common in all jeeps & chrysler cars in general) either blower switch (replaced), blower fan resistor (replaced), and / or blower fan itself. blower switch assembly melted, which could lead to a potential fire. *tr | |||
| VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||
| 06/14/2006 | 30000 | 1 | |
| The a/c,heater blower switch mopar part 305011214aa over heats and the wiring start to melt,the switch starts to melt and then the switch fails. there appears to be to much current draw from the blower motor. it causes the dark green power lead connected to the switch to overheat melting the insulation on the lead and the connections on the switch. this has occured again today september 22,2012. this caused the same problem,wires overheat,connections and wires melt and switch housing at connections start to smolder until switch fails,when switch fails current ceasses to flow to blower motor and everything cools down enough to prevent further damage to switch wiring. fuse for the circuit does not blow out. to repair, switch must be replaced and new wire connectors insalled,and the dark green wire will start to get hot enough to be uncomfable to the touch. dealership parts dept. employees have confirmed that these switch fail regularly., *tr | |||
| 07/31/2012 | 113882 | 1 | |
| The dash blower control was not working. when the mechanic check it and the system, it was discovered that the blower had over heated the pigtail connectors and melted them. the blower control was visibly melted and multiple signs of overheating were apparent. the blower control, all pigtail connectors and the blower had to be replaced. this was caught just short of me having to deal with a fire being caused by this over heating of the electrical parts of the a/c-heater system. this is the same situation as reported in other complaints. refer to odi id numbers: 10364281, 10283272, 10181912 and 10145512. *tr | |||
| 03/17/2002 | 8 | 05/08/2001 | |
| While driving transmission starts to slip.*ak a new transmission had to be installed. there was a leaking tank seal. water leaks through the a/c and heater hoses. there are holes at the bulk head. theres a faulty key cylinder. the passenger door is difficult to open and close. there are 2 recalls on this vehicle. one for a faulty ignition switch and the other for hte intake manifold. *jg | |||
| VISIBILITY - DEFROSTER/DEFOGGER SYSTEM - WINDSHIELD - BLOWER | |||
| 12/06/2007 | 1 | ||
| Multiple failures of the heating fan blower motor switch and the fan resistor. *tr | |||
| VISIBILITY - WINDSHIELD | |||
| 10000 | 1 | ||
| Water came into the front of the vehicle through the windshield because it was not sealed properly. *nlm | |||
| VISIBILITY - WINDSHIELD WIPER/WASHER | |||
| 3 | 03/15/2001 | ||
| The windshield wiper fluid reservoir was not holding fluids, consumer took the vehicle to the dealer on 3 occasions only to be told there were no leaks and a new reservoir would be ordered, however consumers cousin later determined that the hose was never capped when the hard top was removed from the vehicle and the soft top was installed.*jb | |||