Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||||
| 985A6 | 03/18/1998 | 601004 | Some vehicles may cycle when brakes are applied on rough roads or on an incline while making a sharp turn. *yc | 12/14/2000 | |
| 95212 | 10/01/1995 | 46478 | The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par | 04/25/1996 | |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||||
| 985A13 | 03/18/1998 | 601012 | The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc | 06/17/1998 | |
| 9562 | 03/01/1995 | 39900 | Roughness concern during brake application. *tw | 11/01/1995 | |
| BC8890950401 | 04/01/1995 | 3031400 | Unknown | 11/01/1995 | |
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE LIGHT | |||||
| 02176 | 09/02/2002 | 10008580 | Lamp-brake-invadvertent disabling of brake shift interlock. *mj | 08/05/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES, AIR - DISC - ROTOR | |||
| 04/01/1997 | 3 | 06/15/1995 | |
| The poor design of the engine gasket as well as the placement of the coolant flow channels in the engine block goes back farther than 1994 and should be covered under recall. additionally, the rotors tend to warp causing a vibration each time the brakes are used. | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 10/21/2003 | 114000 | 1 | |
| When braking hard, the pedal went to the floor resulting in loss of brakes. i had to use the e-brake and pump the regular pedal to stop. brake fluid was leaking from line located in engine compartment next to driver side front wheel well. *la | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 2 | 10/01/1998 | ||
| I bought the car less than a year ago and have paid over a $1,000 in repairs. the day i left the check engine light came on. the dealer re-built the transmission twice, but i'm still having problems. recently i had full front & back brake job. when i bought the car the brakes were fine. in less than a year i had only 10% brakes left. the day i left i lost all back brakes. a month later it happened again. now they are saying ford has recalled the anti lock system and master cylinder. please help. | |||
| 1 | 08/01/1996 | ||
| Brakes failed. | |||
| 01/01/1992 | 06/01/1992 | ||
| Anti lock brakes failed. | |||
| 07/30/1996 | |||
| The brakes lock up when trying to slow down from highway speeds and a strong odor is present, has anti lock brakes.*ak | |||
| 03/16/1996 | 20 | 02/14/1992 | |
| Abs brakes locked up on dry surface w/some smokingon left front. brake pedal must be pulled up to release brakes when they hang up/stick for no reason on intermittent basis. *ak | |||
| 02/09/1996 | 9 | ||
| Antilock brakes locked up. *sd | |||
| When driving and apply the brake pedal goes to the floor have abs anti-lock brake . tt | |||
| 01/13/1995 | |||
| Failure of the brakes (abs) brakes caused consumer to have an near accident. tt | |||
| 10/01/1995 | |||
| Abs, vibration in the front end of vehicle when brakes are applied. tt | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 11/01/1993 | |||
| We have had numerous and extended repairs on this vehicle. the dealertells us that this vehicle is not listed under the recall notices, however, replacements have been made on motor mounts, struts, brackets, as well as other situations. ford corp. will not assist us. we take excellent care of our vehicles and parts just seem to corrode and fall off. we feel we are entitled to some form of compensation. $4,000 in repairs alone in the past 6 months. prior we have had major brake repairs including seized calipers on both sets and brake booster cable, cooling system failures, head gasket failures, ball joints, springs/coils, struts, etc. i do not understand why this vehicle is not under recall notices, when all indications point to the fact that it is and we are having difficulties in those areas. please assist us in any way possible. we did go through a review process with ford and they are not willing to assist us. the dealer felt they could have given us something towards a new purchase. he also said our only recourse is to go through the legal channels. we are at a point that we have put so much money into the vehicle that our resources are limiting in the purchase of another car. | |||
| 04/28/1997 | 9 | ||
| Brake system continually malfunctions, several repairs made, however fail to rectify failures. | |||
| While vehicle was in park, vehicle surged forward after parking brake was released. also brakes would not stop vehicle when they were applied. dealers stated accelerator cable was faulty. *ak | |||
| 1 | |||
| Brakes failed. | |||
| 03/21/1997 | |||
| Vehicle experienced brake failure while driving when 3/8x 3/8 plastic t on the vacuum system snapped. *ak | |||
| 03/21/1996 | 1 | 11/01/1993 | |
| Failure of the brake pedal, when you apply force to the brake pedal the brake pedal stays in the down postion after taking foot of the brake pedal. *ak consumer was advised by dealer that vacuum power hose booster has a defect.*jb | |||
| 12/07/1992 | 7 | ||
| Brakes failed. | |||
| Compensating valve in brake system when loaded shifts pressure to rear portion of brakes. please describe details. tt | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
| 03/10/1999 | 4 | 06/01/1995 | |
| All 4 brake rotors cut by disc brake pads, although pad lining still exceeds state inspecion requirements. replaced all brake pads and 1 rotor, resurfaced other 3 rotors. defects caused steering and handling problems during braking. | |||
| 10/10/1994 | 0 | ||
| Brakes lock up/pedal vibrates when brakes applied due to warped rotors. *aw | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
| 08/29/1995 | 1 | ||
| Caliper pin broke. | |||
| 10 | 11/10/1991 | ||
| Brake calipers are sticking. | |||
| 05/01/1996 | 1 | ||
| Brake calipers stick. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||
| 02/11/1993 | 8 | 05/05/1992 | |
| Brakes have continually experienced problems with noise and vibration, replacement of rotors and pads on numerous occasions, however continue to fail. mjs | |||
| 05/01/1996 | 1 | ||
| Brake pads failed. | |||
| 12/14/1994 | 1 | ||
| Front brake pads/rotors worn, causing brakes to fail. *skd | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 02/11/1993 | 8 | 05/05/1992 | |
| Brakes have continually experienced problems with noise and vibration, replacement of rotors and pads on numerous occasions, however continue to fail. mjs | |||
| 02/11/1993 | 6 | ||
| At 42,000 miles the vehicle had warped brake rotors replaced 6 times which caused vibration and extended stopping distance. please provide further information. *ak | |||
| 03/21/1994 | 2 | ||
| Brake rotors replaced two times. | |||
| 05/01/1996 | 1 | ||
| Brake rotors failed. | |||
| 03/01/1995 | 1 | 02/01/1992 | |
| When applying the brakes at high speed there was a slight shimmy in the front end. at 48,000 miles the rotors have to be replaced because the pits are too deep to machine out. *ak consuer was advised that rotors were corroded to turn down and would be to thin for safe braking beyond limit, also brake pads were replaced at 48,000.*jb | |||
| 08/23/1996 | 2 | ||
| Front brake rotors machined due to failure. *ak | |||
| 05/25/1995 | |||
| The rear brakes are not stopping the vehicle with the front brakes so the front rotors are warped and it increases the stopping distances. please describe. *ak | |||
| 07/19/1995 | 9 | ||
| Resurfaced front brake drums. | |||
| 09/01/1994 | |||
| Rotors are warped on front brakes, caused vehicle to vibrate. tt | |||
| 03/20/1995 | 3 | ||
| Warped front brake rtors, causing vibration as brakes are applied at highway speeds. *ak | |||
| 12/06/1994 | 6 | ||
| Warped front brake rotors, causing vehicle to vibrate when braking. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM | |||
| 08/25/2000 | 2 | 03/01/1997 | |
| I have had numerous ongoing problems with this car. the check engine lite still comes on intermittenly for no obvious reason and i have replaced the cars whole processor and still have problems. now i have a grinding noise and a vibration when i go to apply my brakes. put new brake shoes on 1 week ago and rotors were in good shape so still have no idea what the problem is now. i have exhaust fumes or gas fumes inside the vehicle at times. please, please help me. i can't afford much more. i have all the basic oil changes done at 3000 miles and have every thing fixed right away. vss has been replaced 3 times now. | |||
| 2 | 10/01/1998 | ||
| I bought the car less than a year ago and have paid over a $1,000 in repairs. the day i left the check engine light came on. the dealer re-built the transmission twice, but i'm still having problems. recently i had full front & back brake job. when i bought the car the brakes were fine. in less than a year i had only 10% brakes left. the day i left i lost all back brakes. a month later it happened again. now they are saying ford has recalled the anti lock system and master cylinder. please help. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - DRUM | |||
| 04/20/1995 | 0 | ||
| Replaced rear shoes/drums . | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - SHOES/LININGS | |||
| 08/29/1995 | 2 | ||
| Front brake boot failed. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | |||
| 11/09/2005 | 180000 | 1 | 06/01/1993 |
| Dt: the contact stated while driving at night the consumer struck a deer and experienced difficulty stopping with the brakes. there was damage to the front hood and headlights. no police report was taken. he drove the vehicle home. upon inspection there was corrosion on brake lines. he suspected this was due to dissimilar metal corrosion and road salts. the vehicle has not been repaired at this time. *ak updated 12/27/05. *jb the brake line burst. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - MASTER CYLINDER | |||
| 2 | 10/01/1998 | ||
| I bought the car less than a year ago and have paid over a $1,000 in repairs. the day i left the check engine light came on. the dealer re-built the transmission twice, but i'm still having problems. recently i had full front & back brake job. when i bought the car the brakes were fine. in less than a year i had only 10% brakes left. the day i left i lost all back brakes. a month later it happened again. now they are saying ford has recalled the anti lock system and master cylinder. please help. | |||
| SERVICE BRAKES, HYDRAULIC - PEDALS AND LINKAGES | |||
| Brakes slowly apply themselves; w/abs, pedal is poor w/no retaining clip to hold up. booster is weak. please describe details. tt | |||
| 03/04/1995 | 4 | ||
| Brake pedal sticks due to a weak return spring, also brake booster failure. *skd | |||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - VACUUM | |||
| 1 | 02/01/1992 | ||
| Power brake booster failed. | |||
| 1 | 01/22/1992 | ||
| Brake pedal is slow in returning to its position. | |||
| 03/21/1996 | 1 | 11/01/1993 | |
| Failure of the brake pedal, when you apply force to the brake pedal the brake pedal stays in the down postion after taking foot of the brake pedal. *ak consumer was advised by dealer that vacuum power hose booster has a defect.*jb | |||
| 02/09/1996 | 9 | ||
| Power brake booster failed. *sd | |||
| 10/10/1994 | 0 | ||
| Power brake booster replaced. | |||
| Brakes slowly apply themselves; w/abs, pedal is poor w/no retaining clip to hold up. booster is weak. please describe details. tt | |||
| 06/13/1995 | 1 | ||
| Brake booster failure, vehicle hesitates when braking. tt | |||
| 06/30/1994 | 1 | ||
| Replaced vacuum brake booster. | |||
| 09/16/1994 | 1 | ||
| Replaced power brake booster. *ak | |||