Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
| 07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
| Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
| Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
| Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
| Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||||
| 736313 | 06/01/1997 | 52563 | Reduced engine performance, restricted fuel flow (clean fuel tank, replace in-line fuel filter and fuel pump strainer). *tw | 08/14/1997 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
| 971101776304 | 11/01/1997 | 54066 | Subject pertaining to driveability symptoms due to fuel injector deposits. *yc | 03/30/1998 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
| 98776304A | 02/01/1998 | 600282 | Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc | 05/05/1998 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
| 11/13/2000 | 2 | ||
| While traveling at speeds over 50 mph vehicle will start to shake to the point where vehicle can lose control if in the rain. contacted dealer, and the dealer noted that fuel injection system is the problem. *ak dealer performed an injector service, throttle body service, added an adative to clean the valves, replaced the fuel filter, wires, plugs, relay, and the fuel pump, however repairs did not remedy problem. *tt | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| 12/19/1998 | |||
| Consumer would fill tank and later the fumes would be very loud. if over night there would be a puddle of gasoline, only if the tank was full. mechanic replaced the tank and found a hole in the upper area, (consumer still has the tank with the hole). | |||
| FUEL SYSTEM, OTHER | |||
| 06/05/1998 | 08/01/1995 | ||
| The gas gauge reads incorrectly. in addition, transmission/transaxle/brakes/seatbacks/electrical system/idle speed control unitand hazard lights failed. *ak | |||