Yamaha Yp400 2007

Model Yp400 made in 2007 by Yamaha got 1 consumer complain, 1 investigation there are 2 recalls as well as 1 service bulletin. Consumer complaints with reference to electrical system. . Technical service bulletines regarding engine and engine cooling. The car had one investigation (electrical system). There was one recall concerning fuel system, gasoline .

Yp400 year 2007

Recalls
Technical Service Bulletins
Defect investigations
Consumer Complaints

Model 2007

Recalls

Campaign	Manufacturer	Manufacturing date	Type	# of units affected	Date Owner notified Mfg	Recall Initiated by	Manufacturers of recalled vehicles/products	Report Recieved Date	Record Creation Date
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
07V219000	YAMAHA MOTOR CORPORATION, USA	from 07/01/2004 to 04/30/2007	V (Vehicle)	13958	06/18/2007	MFR	YAMAHA MOTOR CORPORATION, USA	05/24/2007	05/24/2007
Defect Summary	On certain motorcycles, a leak at the fuel pump seal may allow fuel leakage.
Consequence Summary	Fuel leakage, in the presence of an ignition source, could result in a fire.
Corrective Summary	Dealers will replace the fuel pump seal free of charge. the recall began on june 18, 2007. owners may contact yamaha at 1-800-962-7926.
Notes	Customers may contact the national highway traffic safety administration
08V180000	YAMAHA MOTOR CORPORATION, USA	from 07/01/2004 to 04/30/2007	V (Vehicle)	9600	05/09/2008	ODI	YAMAHA MOTOR CORPORATION, USA	04/23/2008	04/22/2008
Defect Summary	Yamaha is recalling 9,600 my 2006-2007 cp250 and my 2005-2007 yp400 motorcycles. the engine could stall and be difficult to restart because the wire terminals in the fuel pump wire coupler have corroded. water can enter from the main wire harness end and run through the harness to the fuel pump coupler.
Consequence Summary	If the water remains in the coupler for an extended period of time, the terminals can become corroded, which can prevent the fuel pump from operating properly. if this corrosion affects fuel pump operation while the scooter is being ridden, there could be a crash resulting in injury or death.
Corrective Summary	Dealers will install a sub-harness which is designed to allow any water between the wire harness and the fuel pump to drain out before it reaches the fuel pump. the dealer will also inspect the connectors. if either the main wire harness connector or the fuel pump connectors is already corroded, the corresponding assembly(ies) will also be replaced. the recall began on may 9, 2008. owners may contact yamaha at 1-800-962-7926.
Notes	Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

Bulletins

Bulletin	Bulletin date	Replacement Bulletin	Item no.	Summary	Added
ENGINE AND ENGINE COOLING - ENGINE
2007012	06/21/2007		10022493	Coupler corrosion makes engine difficult to start. *kb	08/15/2007

Investigations

NHTSA ID	Manufacturer	Date open	Date close	Subject	Recall campaign
ELECTRICAL SYSTEM
PE08018	YAMAHA MOTOR CORPORATION, USA	03/18/2008	05/13/2008	MOTORSCOOTER STALLING	08V180000
	Odi opened this pe based on owner and ewr field reports alleging the subject scooters would stall while underway.after opening this investigation, yamaha decided to conduct a corrective safety recall (08v-180) in lieu of responding an odi information request.with that recall, this pe is closed.

Consumer Complaints

Fail date	miles	occurences
ELECTRICAL SYSTEM
06/08/2008	480	1
	Scooter stalls and is hard to start again. just purchased the scooter less than 60 days ago and it is unreliable as we have been stuck twice in one day. *tr