Ford Club Wagon 1994
Model Club Wagon made in 1994 by Ford got 38 consumer complains as well as 1 recall. Consumer complaints with reference, among others things, to air bags and electrical system. There was one recall concerning vehicle speed control .
Model 1994
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| VEHICLE SPEED CONTROL | ||||||||||||||||
| 06V286000 | FORD MOTOR COMPANY | V (Vehicle) | 1200000 | 08/07/2006 | ODI | FORD MOTOR COMPANY | 08/01/2006 | 08/02/2006 | ||||||||
| Defect Summary | On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat. | |||||||||||||||
| Consequence Summary | Overheating could result in smoke or burn and an underhood fire. | |||||||||||||||
| Corrective Summary | Dealers will install a fused wiring harness into the speed control system free of charge. the recall began on august 7, 2006. owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388) | |||||||||||||||
| Notes | Ford recall no. 05s28.customers may also contact the national highway traffic safety administration | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| AIR BAGS - FRONTAL | |||
| 11/26/1997 | |||
| When vehicle was involved in a broadside crash there was no deployement of the driver's side air bag. club wagon was traveling about 35-40 mph. the club wagon has been repaired. *ak | |||
| ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
| 01/31/1997 | 7 | 12/12/1996 | |
| Transmission has been replaced 6 times, consumer is requesting reimbursement for the 6th transmission that was not covered under warranty. abs light is illuminated and the front end shakes while braking. vehicle stalled on freeway, check engine light illuminated, fan belt was replaced. heat was coming from rear air conditioner with front air conditioner on, dealer replaced the defective door motor. rear door intermittently won't unlock. regulator/alternator was replaced. consumer is requesting a replacement vehicle. *slc steering wheel makes squeaking nosie. there is tire noise at 25mph. consumer could smell oil from the inside passenger compartment, radiator was also replaced. *slc | |||
| 09/19/1998 | 3 | 06/01/1998 | |
| When backing out of driveway or just driving the van will go into fast gear. you can begin at 0 to 5 mph and in seconds you will be going at least 45 mph sometimes even faster. this can happen any time. the engine can be cold or hot. also we have had to put in a new starter last month. we had the original rebuilt and it died. when we got under the engine we could move a wire and the vehicle started with no problem. the first time that the van died we did have the starter rebuilt. | |||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
| 02/22/2008 | 1 | 05/20/1994 | |
| Recall 08s01, fused jump harness called the dealer, said it would not be available until may 0f 2008. letter received in february. *tr | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 01/31/1997 | 7 | 12/12/1996 | |
| Transmission has been replaced 6 times, consumer is requesting reimbursement for the 6th transmission that was not covered under warranty. abs light is illuminated and the front end shakes while braking. vehicle stalled on freeway, check engine light illuminated, fan belt was replaced. heat was coming from rear air conditioner with front air conditioner on, dealer replaced the defective door motor. rear door intermittently won't unlock. regulator/alternator was replaced. consumer is requesting a replacement vehicle. *slc steering wheel makes squeaking nosie. there is tire noise at 25mph. consumer could smell oil from the inside passenger compartment, radiator was also replaced. *slc | |||
| EQUIPMENT - ELECTRICAL - AIR CONDITIONER | |||
| 01/31/1997 | 7 | 12/12/1996 | |
| Transmission has been replaced 6 times, consumer is requesting reimbursement for the 6th transmission that was not covered under warranty. abs light is illuminated and the front end shakes while braking. vehicle stalled on freeway, check engine light illuminated, fan belt was replaced. heat was coming from rear air conditioner with front air conditioner on, dealer replaced the defective door motor. rear door intermittently won't unlock. regulator/alternator was replaced. consumer is requesting a replacement vehicle. *slc steering wheel makes squeaking nosie. there is tire noise at 25mph. consumer could smell oil from the inside passenger compartment, radiator was also replaced. *slc | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
| 11/01/2000 | 2 | 06/01/1995 | |
| Fuel tank has developed a leak from filler neck which could eventually result in a fire, cause has not been determined.*ak consumer also owns a 2000 year van that was included in recall 01s14 regarding the exact same problem, however consumer was charged for the 1994 year repairs. *slc | |||
| LATCHES/LOCKS/LINKAGES - DOORS - LATCH | |||
| 9 | |||
| The locking mechanism in the side sliding door broke, causing the door not to open. replaced locking mechanism 9 times. please provide details. *ak | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 06/22/2002 | |||
| While applying brakes they locked up, resulting in extended stopping distance. dealer notified.*ak | |||
| 06/17/2000 | 1 | 03/01/1998 | |
| No summary listed for above vehicle. *ak | |||
| 01/31/1997 | 7 | 12/12/1996 | |
| Transmission has been replaced 6 times, consumer is requesting reimbursement for the 6th transmission that was not covered under warranty. abs light is illuminated and the front end shakes while braking. vehicle stalled on freeway, check engine light illuminated, fan belt was replaced. heat was coming from rear air conditioner with front air conditioner on, dealer replaced the defective door motor. rear door intermittently won't unlock. regulator/alternator was replaced. consumer is requesting a replacement vehicle. *slc steering wheel makes squeaking nosie. there is tire noise at 25mph. consumer could smell oil from the inside passenger compartment, radiator was also replaced. *slc | |||
| 02/18/1997 | |||
| The anti-lock brake system has been rebuilt to get the light to go off. when the brakes are applied at 35mhp there is an strong vibration in the vehicle. dealer has been contacted. *ak | |||
| 03/21/1995 | |||
| Intermittent abs brake failure. also abs warning light goes on/off. | |||
| 03/19/1996 | |||
| Driving home in the rain, went to apply the brakes (abs), they failed to catch, vehicle went into spin across 3 lanes of traffic, was hit by another vehicle. *k | |||
| The abs brakes went out no brakes on vehicle. tt | |||
| STEERING | |||
| 02/12/2013 | 167000 | ||
| Hope this isn't a dup; i started a report yesterday, but don't think i completed it. asked to do some work on my 1994 club wagon (167k mi), an independent mechanic found a crack on the lower side of the frame, beneath the steering box. he wouldn't do the work. subsequently a body shop found there were actually two cracks, one on the inboard side of the frame, radiating from the steering box mounting hole, traveling back and down, around the lower corner of the frame, then forward about 3 on the lower face of the frame ,along the edge. the last 2 of the crack were open, with about a 2mm gap. the crack on the opposite face traveled in an arc of perhaps 60 | |||
| 03/21/2012 | 300000 | ||
| As i was leaving the parking lot at cleveland clinic, i heard two loud bangs and upon looking under the hood i noticed the gearbox had pulled from the frame and three bolts sheared off leaving the steering unusable and this incident had i been driving would certainly have resulted in the death of my wife and i. why no recall i ask? upon researching, i am finding many of the same issues from owners of this model. | |||
| 11/26/2011 | |||
| I went to the grocery store with my 3 year old and as i was backing out the steering completely failed i stll cannot get the van home yet because it has yet to be fixed. the steering box separated from the frame, where it was mounted and sheared all 3 bolts and pulled one bolt through the frame.. had i been driving on the highway i would have wrecked. i researched it online and found it to be a pretty common thing in 93'/94' ford clubwagons and ive seen pictures that looked similar to what happened to my aunts van that i was driving. from what i understand there is still currently no recall on that defect and it is a dangerous defect that should be recalled.. | |||
| 11/29/2008 | 165000 | 1 | |
| The steering box is bolted to the front left frame with three bolts. all three bolts sheared, resulting in complete loss of steering ability. the incident occurred at the top of the mt. baker highway, washington state rt 542. there were six people in the van, and we had just driven up the winding steep mountain road with thousand foot drops and few guard rails. the bolts broke as we were parking in front of the ski lodge. had it broken moments sooner or later, there is no doubt that we would all be dead. inspection shows much cracking in the frame at and near the lower bolt hole. *tr | |||
| STEERING - WHEEL AND HANDLE BAR | |||
| 01/31/1997 | 7 | 12/12/1996 | |
| Transmission has been replaced 6 times, consumer is requesting reimbursement for the 6th transmission that was not covered under warranty. abs light is illuminated and the front end shakes while braking. vehicle stalled on freeway, check engine light illuminated, fan belt was replaced. heat was coming from rear air conditioner with front air conditioner on, dealer replaced the defective door motor. rear door intermittently won't unlock. regulator/alternator was replaced. consumer is requesting a replacement vehicle. *slc steering wheel makes squeaking nosie. there is tire noise at 25mph. consumer could smell oil from the inside passenger compartment, radiator was also replaced. *slc | |||
| STRUCTURE - BODY - DOOR | |||
| 01/31/1997 | 7 | 12/12/1996 | |
| Transmission has been replaced 6 times, consumer is requesting reimbursement for the 6th transmission that was not covered under warranty. abs light is illuminated and the front end shakes while braking. vehicle stalled on freeway, check engine light illuminated, fan belt was replaced. heat was coming from rear air conditioner with front air conditioner on, dealer replaced the defective door motor. rear door intermittently won't unlock. regulator/alternator was replaced. consumer is requesting a replacement vehicle. *slc steering wheel makes squeaking nosie. there is tire noise at 25mph. consumer could smell oil from the inside passenger compartment, radiator was also replaced. *slc | |||
| STRUCTURE - FRAME AND MEMBERS | |||
| 11/29/2008 | 165000 | 1 | |
| The steering box is bolted to the front left frame with three bolts. all three bolts sheared, resulting in complete loss of steering ability. the incident occurred at the top of the mt. baker highway, washington state rt 542. there were six people in the van, and we had just driven up the winding steep mountain road with thousand foot drops and few guard rails. the bolts broke as we were parking in front of the ski lodge. had it broken moments sooner or later, there is no doubt that we would all be dead. inspection shows much cracking in the frame at and near the lower bolt hole. *tr | |||
| TIRES | |||
| 01/31/1997 | 7 | 12/12/1996 | |
| Transmission has been replaced 6 times, consumer is requesting reimbursement for the 6th transmission that was not covered under warranty. abs light is illuminated and the front end shakes while braking. vehicle stalled on freeway, check engine light illuminated, fan belt was replaced. heat was coming from rear air conditioner with front air conditioner on, dealer replaced the defective door motor. rear door intermittently won't unlock. regulator/alternator was replaced. consumer is requesting a replacement vehicle. *slc steering wheel makes squeaking nosie. there is tire noise at 25mph. consumer could smell oil from the inside passenger compartment, radiator was also replaced. *slc | |||
| UNKNOWN OR OTHER | |||
| 02/12/2013 | 167000 | ||
| Hope this isn't a dup; i started a report yesterday, but don't think i completed it. asked to do some work on my 1994 club wagon (167k mi), an independent mechanic found a crack on the lower side of the frame, beneath the steering box. he wouldn't do the work. subsequently a body shop found there were actually two cracks, one on the inboard side of the frame, radiating from the steering box mounting hole, traveling back and down, around the lower corner of the frame, then forward about 3 on the lower face of the frame ,along the edge. the last 2 of the crack were open, with about a 2mm gap. the crack on the opposite face traveled in an arc of perhaps 60 | |||
| VEHICLE SPEED CONTROL - CRUISE CONTROL | |||
| 06/26/2007 | 229000 | 2 | 11/01/1994 |
| Tl*the contact owns a 1994 ford club wagon. while driving 65 mph, the contact activated the cruise control, which resulted in a total loss of power for the vehicle. the dealer stated that the cause of failure was the distributor and they made the replacement. approximately 60 miles later, the failure recurred when the cruise control was activated. the vehicle was taken to another dealer who stated that the distributor had failed again. as of july 3, 2007, the vehicle has not been repaired. the current and failure mileages were 229,000. updated 09/18/07. *jb | |||
| WHEELS | |||
| 11/01/2093 | |||
| These vans operate with the rear wheel displaced from the front wheel track by 2.5 in. mr | |||