Gmc C1500 2002
Model C1500 made in 2002 by Gmc got 3 consumer complains there are 5 investigations as well as 1 service bulletin. Consumer complaints with reference, among others things, to power train, service brakes, hydraulic and structure. Technical service bulletines regarding steering. The car had one investigation (parking brake).
Model 2002
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STEERING - HYDRAULIC POWER ASSIST - PUMP | |||||
| SB-06-02-32-013B | 08/01/2009 | 10032462 | Saab/hummer/gm: diagnostic tips/recommendations when power steering pump replacement is necessary. analysis of returned power steering (ps) pumps that had been replaced for noise, no power assist, no or low pressure and leaking conditio | 03/26/2010 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| PARKING BRAKE | ||||||
| PE03057 | GENERAL MOTORS CORP. | 12/08/2003 | 04/09/2004 | PARKING BRAKE FAILURE | ||
| Odi opened pe03-057 to assess parking brake ineffectiveness in the subject vehicles.these vehicles are equipped with four wheel disc brakes that incorporate a single-shoe drum-in-hat parking brake independent of the service brakes.complaint and warranty data indicate that the parking brake linings tend to wear out early in the life of the vehicle (at an average of 24 months in service), reducing the parking brake system's torque below that needed to immobilize the vehicle.gm has attributed this accelerated wear to foreign material intrusion and a failure of the brake shoe to properly self-center within its brake drum.effective with the start of my 2003 production, a newer reduced force hold-down clip was introduced to facilitate brake shoe disengagement from the drum surface.this part is also available at the service level for the my 1999-2002 vehicles.gm has indicated that the paking brake is intended to operate in conjunction with the transmission to immobilze parked vehicles, and that in many cases, accelerated parking brake lining wear is caused by rough use, vehicle modifications, and driving with the parking engaged. odi has upgraded the preliminary evaluation to an engineering analysis to gather further information concerning parking brake usage factors and the circumstances surrounding the seventeen reported vehicle crashes. | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL - LINKAGE AND CABLE | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 12/08/2003 | 83579 | 2 | 10/19/2002 |
| On dec 8, 2003 i was driving at approx. 45 miles per hour when my transmission shifted out of gear and then after a few secounds it shifted into low gear, all on its own. there was a car traveling behind that almost hit me from behind. i pulled over and put my truck in park. i looked under my truck to see if any thing had come apart. i did not see any fluid leak or any loose parts. i drove my truck to the dealership in low gear. they took my truck in for repairs (38,127 miles). i was 2,127 miles out of warranty. the transmission was repaired and it cost $1,057.19. today 3/30/05 on my way home from work the transmission does the same thing. i only have low gear and no reverse. this time i was lucky that no one was behind me when it happened. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | |||
| 01/18/2003 | 29100 | 1 | 12/27/2002 |
| Rear brake fulid and emergency line is exposed and easily damaged by road debris and/or rubble. 2wd c1500 trucks have brake lines and cables drooping down beyond below rear shock absorbers and are easily snagged by road trash.*jb causing loss of fulid and braking ability. | |||
| STRUCTURE - BODY - TAILGATE - HINGE AND ATTACHMENTS | |||
| 10/21/2005 | 76000 | 1 | 01/15/2000 |
| I sat on my tail gate and the tail gate fell down. when i looked i had one broke cable and the other side the bolt was missing. i bought two cables from advance auto replaced one side but i could not get the bolt back in the other side. i was planning to take the truck to the dealer the following weekend for the recall but the gate fell off the truck and i did not know it had fell off and i dragged it down a dirt road for about half mile or more. i tried to get gmc to replace the tail gate but they just wanted to replace the cable saying that the cable did not cause the tail gate to fall off and the damage was not due to the cables. i feel that the cable problem caused the tail gate to fall off. *jb | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| LA | LAFAYETTE | 70503 | COUTESY GMC | 337-984-1462 |