Gmc Yukon Xl 2500 2004
Model Yukon Xl 2500 made in 2004 by Gmc got 16 consumer complains there is 1 recall as well as 8 service bulletins. Consumer complaints with reference, among others things, to service brakes, hydraulic, structure and suspension. Technical service bulletines regarding equipment, exterior lighting and fuel system, other. There was one recall concerning fuel system, gasoline .
Model 2004
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||||||||||||
06E043000 | HONEYWELL INTERNATIONAL, INC. | E (Equipment) | 88303 | 10/18/2006 | MFR | GENERAL MOTORS CORP. | 05/19/2006 | 05/22/2006 | ||||||||
Defect Summary | Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line. | |||||||||||||||
Consequence Summary | This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur. | |||||||||||||||
Corrective Summary | Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1). | |||||||||||||||
Notes | This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EQUIPMENT - ELECTRICAL - AIR CONDITIONER | |||||
PI-5141 | 01/01/2012 | 10043536 | Buick/cadillac/chevrolet/gmc/oldsmobile: if blower motor is set to any speed position and when key is off, it becomes inoperative and may still be inoperative after key is turned on. *pe | 04/09/2012 | |
EXTERIOR LIGHTING - TURN SIGNAL - FLASHER UNIT | |||||
070842013 | 09/01/2007 | 10023217 | Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj | 11/02/2007 | |
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
3046A | 3046B | 10009382 | Fuel gauge fluctuation in park or neutral. *tt | 09/27/2004 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
08-07-30-015 | 04/01/2008 | 10025462 | Diagnostic information on mn8, mt1 ses/mil illuminated, dtc p0757, harsh shift, delayed 2-3 shift, 2-3 shift flare, no third gear, slips in third gear or reverse. *pe | 08/12/2008 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
3061 | 12/01/2007 | 3061F | 10023773 | Dtc c0327 with or without additional dtc's setting. with four wheel drive (4wd) only. *nj | 01/31/2008 |
STRUCTURE - FRAME AND MEMBERS | |||||
PIT-3749D | 11/01/2010 | 10037570 | Ready | 05/25/2011 | |
PIT-3749D | 11/01/2010 | 10037570 | Gm: on some truck models there is some frame corrosion. *rm | 05/25/2011 | |
TIRES - PRESSURE MONITORING AND REGULATING SYSTEMS | |||||
PIT3569 | 02/01/2008 | PIT3569C | 10024342 | Low tire light on and/or dic check tire pressure message when cold, with rpo uj6. *nj | 04/07/2008 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, HYDRAULIC | |||
04/14/2010 | 31985 | ||
Noticed that additional force on the brake pedal was required in order to stop the vehicle. brought into dealer and they stated that the backside of the rotor is rusted away and that there is only 1/4 of an inch of contact on the rear side of all 4 rotors. vehicle has 30,000 miles and is out of warranty, dealer said corrosion is normal in the northesat and now wants $1,000 for a new brake job. | |||
STRUCTURE - BODY | |||
05/25/2012 | 157000 | ||
I just bought this vehicle from community ford in indiana. i got up underneath the vehicle and found the frame is severly rusted and cracked at the factory installed frame hitch mount points. as if the tongue weight to a trailer was over the rated limit. i have read several posts on forums dealing with this issue and it seems to be a common issue in 2500hd trucks of this year and 2005.i have also noticed my rear crossmember is severly corroded along with other parts of the frame. | |||
SUSPENSION | |||
05/25/2012 | 157000 | ||
I just bought this vehicle from community ford in indiana. i got up underneath the vehicle and found the frame is severly rusted and cracked at the factory installed frame hitch mount points. as if the tongue weight to a trailer was over the rated limit. i have read several posts on forums dealing with this issue and it seems to be a common issue in 2500hd trucks of this year and 2005.i have also noticed my rear crossmember is severly corroded along with other parts of the frame. | |||
UNKNOWN OR OTHER | |||
05/25/2012 | 157000 | ||
I just bought this vehicle from community ford in indiana. i got up underneath the vehicle and found the frame is severly rusted and cracked at the factory installed frame hitch mount points. as if the tongue weight to a trailer was over the rated limit. i have read several posts on forums dealing with this issue and it seems to be a common issue in 2500hd trucks of this year and 2005.i have also noticed my rear crossmember is severly corroded along with other parts of the frame. |