International 7600 2006
Model 7600 made in 2006 by International got 4 recalls as well as 6 service bulletins. Technical service bulletines regarding engine and engine cooling and power train. There were some recalls concerningengine and engine cooling and parking brake.
Model 2006
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||||||||||||
05V567000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | V (Vehicle) | 6848 | 12/21/2005 | MFR | NAVISTAR, INC | 12/21/2005 | 12/21/2005 | ||||||||
Defect Summary | On certain heavy duty trucks equipped with caterpillar diesel engines, the engine electrical ground cable that connects the engine block with the starter may be routed in a way that could cause chafing against the starter's positive battery cables. | |||||||||||||||
Consequence Summary | If chafing occurs between the positive and negative cables, an electrical short may result and may cause a vehicle fire, possibly resulting in property damage, personal injury or death. | |||||||||||||||
Corrective Summary | Dealers will inspect the engine ground cables for proper routing. if any chafing is found, the engine block ground cable will be replaced with a shorter (280mm) cable and any other damaged cables will be replaced and routed correctly free of charge. the recall began on december 21, 2005. owners may contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no.05523.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
PARKING BRAKE | ||||||||||||||||
07V314000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 11/01/2005 to 04/30/2007 | V (Vehicle) | 10882 | 09/28/2007 | MFR | NAVISTAR, INC | 07/24/2007 | 07/24/2007 | |||||||
Defect Summary | On certain 6x4 or 6x6 trucks with air brakes or tractors with air brakes and equipped with bendix sr-7 spring brake modulating valves, the internal rubber check valve may leak causing a delay in the application of the spring brakes to park the vehicle after the operator pulls the dash valve button. | |||||||||||||||
Consequence Summary | This could delay or failure in applying the parking brakes which could result in a vehicle roll away, increasing the risk of a crash. | |||||||||||||||
Corrective Summary | International is working with bendix to repair these vehicles (please see 07e-037). bendix will install a check valve repair kit for the affected sr-7 spring brake modulating valve free of charge. the recall began on september 28, 2007. owners may contact bendix at 440-329-9000 and international at 440-329-9179. | |||||||||||||||
Notes | International recall no. 07511.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
POWER TRAIN - AXLE ASSEMBLY | ||||||||||||||||
05V449000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 06/14/2005 to 06/16/2005 | V (Vehicle) | 4 | 10/07/2005 | MFR | NAVISTAR, INC | 10/04/2005 | 10/04/2005 | |||||||
Defect Summary | On certain heavy duty truck/tractors equipped with arvinmeritor series 145 and 160 rear drive axles. the suspect rear drive axle's spindles may have been incorrectly heat treated. such a condition lessens the overall structural integrity of the spindles and could result in its fracture. | |||||||||||||||
Consequence Summary | If a spindle fractures while the vehicle is in motion, it may cause wheel separation, which could, without warning result in a vehicle crash. | |||||||||||||||
Corrective Summary | Dealers will inspect the suspect vehicles and if the spindles are found to have certain date codes, the axle will be replaced. the recall began on october 7, 2005. owners may contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no. 05520.customers may also contact the national highway traffic safety administration | |||||||||||||||
TRAILER HITCHES - FIFTH WHEEL ASSEMBLY | ||||||||||||||||
05V188000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 10/10/2001 to 03/21/2005 | V (Vehicle) | 4616 | 08/05/2005 | MFR | NAVISTAR, INC | 04/28/2005 | 04/29/2005 | |||||||
Defect Summary | On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. this could result in inadvertent operation of the fifth wheel slide control. | |||||||||||||||
Consequence Summary | If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning. | |||||||||||||||
Corrective Summary | Dealers will relocate the msva 7-pack to a less water intensive environment. a new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. the recall began on august 5, 2005. owners may contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no.05511. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
AFC-08915 | 08/01/2008 | 10027584 | Navistar: some engine fan blades equipped with caterpillar and cummins engines have experienced cracking. *pe | 01/26/2009 | |
071214 | 09/01/2007 | 10023454 | International truck and engine corporation - severe service fan blade failures. *nj | 12/12/2007 | |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
AFC-08915 | 08/01/2008 | 10027584 | Navistar: some engine fan blades equipped with caterpillar and cummins engines have experienced cracking. *pe | 01/26/2009 | |
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT | |||||
061401 | 05/01/2006 | 10020387 | New rear axle shaft flange mounting hardware for 5000i, 7000 hpv, and 8000 hpv models built after may 8, 2006 and be, ce, fe, re bus, 1000, 4000 hpv, and 9000i models built after june 5, 2006. *tt | 09/26/2006 | |
POWER TRAIN - MANUAL TRANSMISSION - FLOOR SHIFT ASSEMBLY | |||||
IK 1300064 | 07/15/2008 | 10025942 | International: manual shift lever jumps out of gear on 7000's and 8000's vehicles. 7600 (1/1/02-2/1/08); 7700 (1/1/04-2/1/08): 8600 (1/1/02-2/1/08). *pe | 09/17/2008 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
061302 | 05/01/2006 | 10020357 | Guidelines to ensure satisfactory performance of meritor transfer case models mtc-4208, mtc-4210, mtc-4213 in certain international 7000 hpv models. *tt | 09/20/2006 |