Kenworth T800 1998
Model T800 made in 1998 by Kenworth got 1 consumer complain there are 8 recalls as well as 7 service bulletins. Consumer complaints with reference to service brakes, air. . Technical service bulletines regarding engine and engine cooling. There were some recalls concerningelectrical system, equipment and service brakes, air.
Model 1998
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - IGNITION - MODULE | ||||||||||||||||
99V181001 | PACCAR, INCORPORATED | from 12/01/1998 to 06/30/1999 | V (Vehicle) | 272 | MFR | PACCAR INCORPORATED | 07/09/1999 | 07/14/1999 | ||||||||
Defect Summary | Vehicle description: heavy duty trucks equipped with caterpillar engines and eaton autoshift transmissions. the engines can stall because of software problems. | |||||||||||||||
Consequence Summary | Increased steering effort can occur. | |||||||||||||||
Corrective Summary | Dealers will update these engines with software changes. caterpillar is conducting the owner notification and remedy of this recall. | |||||||||||||||
Notes | Owner notification is expected to begin during august 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1-206-828-5418 or peterbilt at 1-940-591-4000.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | ||||||||||||||||
98V129000 | PACCAR, INCORPORATED | from 06/01/1996 to 05/31/1998 | V (Vehicle) | 9500 | 07/02/1998 | MFR | PACCAR INCORPORATED | 06/11/1998 | 06/17/1998 | |||||||
Defect Summary | Vehicle description: heavy duty trucks equipped with caterpillar 3406e engines. the routing of the electrical and fuel lines can cause chaffing of the wiring harness on the fuel line. | |||||||||||||||
Consequence Summary | This chaffing can cause fuel leakage and a potential for a fire in the engine compartment. | |||||||||||||||
Corrective Summary | Dealers will inspect, adjust, and repair, if necessary, the fuel line and electrical harness. | |||||||||||||||
Notes | Owner notification is expected to begin during july 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1-206-828-5418.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
EQUIPMENT - OTHER - LABELS | ||||||||||||||||
01V142000 | PACCAR, INCORPORATED | from 10/01/1994 to 01/31/2001 | V (Vehicle) | 14 | 06/22/2001 | MFR | PACCAR INCORPORATED | 04/24/2001 | 04/26/2001 | 567 | ||||||
Defect Summary | Vehicle description: heavy duty trucks equipped with meritor fg941 steer axles. the gross axle weight rating (gawr) was determined incorrectly and over-stated on the vehicle certification label. with the incorrect gawr listed, these labels do not meet the certification requirements of part 567, requirements for manufacturers of motor vehicles. vehicles will be remedied either by assigning the proper weight rating or, if possible, by changing the necessary components to meet the currently assigned weight rating. | |||||||||||||||
Consequence Summary | These vehicles would not be in compliance with federal regulations. | |||||||||||||||
Corrective Summary | Vehicles will be remedied either by assigning the proper weight rating or, if possible, by changing the necessary components to meet the currently assigned weight rating. owner notification began june 22, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1-425-828-5000. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SERVICE BRAKES, AIR | ||||||||||||||||
03V126000 | PACCAR INCORPORATED | from 01/21/1991 to 02/25/2003 | V (Vehicle) | 45 | 05/05/2003 | MFR | PACCAR INCORPORATED | 03/31/2003 | 04/02/2003 | 571 | 121 | |||||
Defect Summary | Certain trucks equipped with meritor p 18x7 brakes with 36 | |||||||||||||||
Consequence Summary | This does not meet the requirements of the standard. | |||||||||||||||
Corrective Summary | Dealers will add an additional tank or change one of the existing air tanks to a larger size. owner notification began on may 5, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1-425-828-5440. | |||||||||||||||
Notes | Kenworth recall no. 03kw3. customers can also contact the national highway traffic safety administration | |||||||||||||||
SUSPENSION - FRONT - CONTROL ARM - LOWER ARM | ||||||||||||||||
01V051000 | PACCAR, INCORPORATED | from 02/19/1996 to 02/09/2001 | V (Vehicle) | 209 | 03/27/2001 | MFR | PACCAR INCORPORATED | 02/20/2001 | 02/28/2001 | |||||||
Defect Summary | Vehicle description: vehicles equipped with 54 rear axle spacing configuration of the airglide 200 suspension with the service application identified as logger, dump truck, or tanker. the rear suspension is regularly subjected to extreme articulation, resulting in flexing of the joint. | |||||||||||||||
Consequence Summary | Failure of the lower sway arm attaching bolts could result in loss of vehicle control. | |||||||||||||||
Corrective Summary | Dealers will replace the lower sway arm brackets. owner notification began march 27, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1-425-828-5000. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SUSPENSION - FRONT - HUB | ||||||||||||||||
03V125000 | PACCAR INCORPORATED | from 09/02/1998 to 12/06/2001 | V (Vehicle) | 154 | 07/16/2003 | ODI | PACCAR INCORPORATED | 04/01/2003 | 04/15/2003 | |||||||
Defect Summary | On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely. | |||||||||||||||
Consequence Summary | Seizure of the bearings can cause wheel separation or wheel end fire. | |||||||||||||||
Corrective Summary | Dealers will replace all front axle hubs. notification began july 16, 2003. the manufacturer has advised us that parts will not be available until september 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy with a reasonable time should contact peterbilt at 940-591-4201 or kenworth 425-828-5440. | |||||||||||||||
Notes | Kenworth recall no. 03kw2 and peterbilt recall no. 303-a.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SUSPENSION - REAR | ||||||||||||||||
02V061001 | PACCAR, INCORPORATED | from 07/09/1998 to 09/22/2000 | V (Vehicle) | 116 | MFR | PACCAR INCORPORATED | 02/27/2002 | 03/05/2002 | ||||||||
Defect Summary | On certain heavy duty trucks equipped with replacement dana spicer tandem drive axle models ds463 and ds521, installed on vehicles from may 1, 2001 through february 1, 2002, an undersized attachment weld may fracture without warning. | |||||||||||||||
Consequence Summary | The loss of this attachment to the vehicle chassis can adversely affect vehicle handling or driver control. | |||||||||||||||
Corrective Summary | Dana is conducting the owner notification and remedy for this campaign. the dealers will remove the suspect bracket, inspect the axle housing, and reweld the bracket to the axle housing. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact dana at 616-567-1088 or kenworth at 425-828-5440. | |||||||||||||||
Notes | Consumers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236. | |||||||||||||||
VEHICLE SPEED CONTROL | ||||||||||||||||
03V245000 | PACCAR INCORPORATED | from 04/01/1995 to 12/31/1997 | V (Vehicle) | 18 | MFR | PACCAR INCORPORATED | 07/09/2003 | 07/17/2003 | ||||||||
Defect Summary | On certain vehicles equipped with cummins electronic control modules on the c8.3g and l10g engines, the ecm does not have the ability to detect a throttle fail-safe engine shutdown command. this could result in an unanticipated, uncommanded open throttle condition without warning. | |||||||||||||||
Consequence Summary | If this event occurs, the vehicle operator will not have control of the engine speed, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Cummins will notify the customers and replace the ecm. owners should contact cummins at 1-800-343-7357 or kenworth at 1-425-828-5440. | |||||||||||||||
Notes | Customers can also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
TIB-E-009 | 12/02/2010 | 10040180 | Ready | 08/16/2011 | |
TIB-E-009 | 12/02/2010 | 10040180 | Paccar: a software update is causing the check engine light to come on. *rm | 08/16/2011 | |
TIB-44-17 | 10/23/2008 | 10027646 | Kenworth trucks: reduced engine power from fuel starvation. any model kenworth equipped with the 2007 emissions compliant isx engine and optional davco 382 fuel filter, built prior to 8/11/08, *pe | 01/27/2009 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
TIB-E-055 | 07/09/2012 | 10045240 | Kenworth: oil collection at cac intake pipe is caused by an imbalance in turbocharger pressures. models t660, t800, t700, and w900. *pe | 08/22/2012 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
TIB-E011 | 12/15/2010 | 10040181 | Ready | 08/16/2011 | |
TIB-E011 | 12/15/2010 | 10040181 | Paccar: engineering standards have changed and there are now engines with heat treated bolts. *rm | 08/16/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
TIB-44-17 | 10/23/2008 | 10027646 | Kenworth trucks: reduced engine power from fuel starvation. any model kenworth equipped with the 2007 emissions compliant isx engine and optional davco 382 fuel filter, built prior to 8/11/08, *pe | 01/27/2009 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, AIR - ANTILOCK | |||
07/01/1998 | |||
Abs light comes on intermittently, abs capability intermittently. *ak |