Newmar Dutch Star 2007
Model Dutch Star made in 2007 by Newmar got 2 recalls as well as 7 service bulletins. Technical service bulletines regarding electrical system and equipment. There were some recalls concerningelectrical system and engine and engine cooling.
Model 2007
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||||||||||||
08V075000 | NEWMAR CORPORATION | V (Vehicle) | 409 | MFR | NEWMAR CORPORATION | 02/20/2008 | 02/20/2008 | |||||||||
Defect Summary | Newmar is recalling 409 my 2007-2008 all star, dutch star, ventana, and kountry star diesel pushers motor home chassis. there may be a loose connection between the bus bar and a grid pad due to the pins being slightly smaller diameters after assembly. electrical power may be lost to components of the major chassis operating systems (engine, transmission, starting, cooling) causing the vehicle to shut down and/or not be capable of powering up. | |||||||||||||||
Consequence Summary | Each vehicle could potentially experience a unique circumstance where one or a combination of the following conditions could occur: loss of electrical power to the engine, transmission, starting and engine cooling systems, operation of the right chassis stop/turn signal and right trailer stop/turn signal, the anti-lock brake system, auxiliary brake system, the heater elements in the air dryer, and the heater element in the water-in- fuel separator. | |||||||||||||||
Corrective Summary | Newmar is working with spartan to repair these motor homes (please see 07v363). the dvec bussmann box will be replaced. owners may contact spartan at 1-517-543-6400 or newmar at 574-773-7791. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | ||||||||||||||||
07V354000 | NEWMAR CORPORATION | V (Vehicle) | 308 | MFR | NEWMAR CORPORATION | 08/08/2007 | 08/15/2007 | |||||||||
Defect Summary | On certain motor homes built on spartan mm chassis with cummins isl cm850 diesel engines, the connecting rod contains a machining defect in the wrist pin bushing of the rod that could cause a seizure of the piston pin. | |||||||||||||||
Consequence Summary | If allowed to progress, this can lead to engine failure with the possibility of the rod rupturing the lock cavity, spilling oil and debris onto the roadway increasing the risk of a vehicle crash. | |||||||||||||||
Corrective Summary | Newmar is working with spartan and cummins to recalibrate the engine control module and enhance the engine protection system enabling it to provide early detection of the failure mode and avoid more serious engine damage and resultant safety hazard. cummins will also install a new valve cover with a crankcase pressure sensor free of charge (please see 07e033). owners may contact cummins at 1-800-343-7357 , spartan at 517-543-6400, or newmar at 1-574-773-7791. | |||||||||||||||
Notes | Newmar recall no. spec 07008.customers may also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM - SOFTWARE | |||||
338 | 03/24/2008 | 10024681 | [engine brake] light function was programmed (disabled) in [engine programming parameters]. *nj | 05/05/2008 | |
EQUIPMENT | |||||
343 | 06/02/2008 | 10025862 | Newmar corporation: all motorized rv. a thermal limit switch is added to certain 1200 lr, 1200 lrim, and 1201 lrim refrigerators to prevent possible excess or overheating conditions in the heater area of the cooling unit to exceed a certa | 09/11/2008 | |
EQUIPMENT - RECREATIONAL VEHICLE | |||||
344 | 06/04/2008 | 10025861 | Newmar corporation: all motorized equipped with norcold refer. change cooling unit heating element vendors; there is a new style electric heating element that must be used in certain new cooling units. *pe | 09/11/2008 | |
EXTERIOR LIGHTING - TURN SIGNAL | |||||
306 | 12/06/2006 | 10022875 | Optical warning devices - turn signal stalk operation is awkward. spartan campaign tsb06-540-0002 mh586. *nj | 10/02/2007 | |
STEERING - HYDRAULIC POWER ASSIST - POWER STEERING FLUID | |||||
341 | 05/23/2008 | 10025348 | Steering gear seal leaks fluid. *pe | 07/30/2008 | |
SUSPENSION - FRONT | |||||
TSB-340 | 04/18/2008 | 10026546 | Newmar: popping or grinding noises in the front end when ifs suspension is articulating. *pe | 11/07/2008 | |
UNKNOWN OR OTHER | |||||
337 | 03/24/2008 | 10024686 | Discoloration in the refrigerator enclosure wall adjacent to the flue exhaust on norcold 1200lr refrigerators. concern is that the discoloration is due to exposure to heat from the flue. *nj | 05/05/2008 |