Porsche Cayenne 2003
Model Cayenne made in 2003 by Porsche got 6 investigations there is 1 recall as well as 27 service bulletins. Technical service bulletines regarding air bags, electrical system and engine and engine cooling. The car had one investigation (air bags). There was one recall concerning seat belts .
Model 2003
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SEAT BELTS | ||||||||||||||||
04V593000 | PORSCHE CARS NORTH AMERICA, INC. | to 09/30/2004 | V (Vehicle) | 31000 | 05/17/2005 | OVSC | PORSCHE CARS NORTH AMERICA, INC. | 12/15/2004 | 12/20/2004 | 571 | 208 | |||||
Defect Summary | Certain passenger cars fail to comply with the requirements of federal motor vehicle safety standard no. 208, occupant crash protection. all three rear seat positions and the front passenger position are equipped with seat belt retractors that have a locking feature which converts the retractor from an emergency locking retractor (elr) mode to an automatic locking retractor (alr) mode for the purposes of child restraint installation. the belt may deactivate the alr mode with certain child restraints. | |||||||||||||||
Consequence Summary | When involved in a crash, the child restraints may not be properly secured increasing the risk of injury or death to the seat occupant. | |||||||||||||||
Corrective Summary | Dealers will permanently install a clip in either of the affected rear outboard seat belts and provide an owner's manual insert. the clips will prevent unwarranted conversion from alr to elr mode with child seat installation. the recall began may 17, 2005. owners should contact porsche at 1-800-545-8039. | |||||||||||||||
Notes | Porsche recall no. a506.customers can also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
AIR BAGS | |||||
6963 | 09/01/2004 | 10015912 | Airbag warning light on: fault code 1217 and 1218. *sc | 08/16/2005 | |
AIR BAGS - SIDE/WINDOW | |||||
24-07 | 06/29/2007 | 10026424 | Porsche: w725- replacing side airbag wire harness plug connection (workshop campaign). *pe | 10/28/2008 | |
ELECTRICAL SYSTEM | |||||
6005 | 11/11/2005 | 10018436 | Electric malfunctions due to water leakage in the interior of the vehicle. *tt | 12/22/2005 | |
0515 | 09/14/2005 | 10016911 | Miscellaneous lamp warnings in the instrument cluster. *tt | 10/17/2005 | |
1404 | 11/18/2004 | 10011947 | Moisture entering the psm contact plugs in main harness may activate the psm warning light in instrument cluster. *tt | 02/07/2005 | |
9436 | 10/09/2004 | 10010640 | Electrical malfunctions due to sticking brake light switch. *tt | 12/03/2004 | |
ELECTRICAL SYSTEM - IGNITION - MODULE | |||||
2820 | 07/05/2007 | 10022371 | Bar ignition modules (coils) with part no. 948.602.104.00 and 948.602.104.01. *kb | 08/09/2007 | |
ENGINE AND ENGINE COOLING | |||||
4495 | 10/01/2004 | 10012467 | Cayenne turbo increased performance kit. *eh | 03/02/2005 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
ATI-1102 | 09/02/2011 | 10041747 | Porsche: check engine light comes on. *pe | 11/02/2011 | |
S-24-08 | 09/03/2008 | 10026870 | Porsche: rough running engine at idle speed. diagnostics on hot film mass air flow sensor (maf). maf sensors that are in perfect working order are being replaced unnecessarily in the dealer's organization. *pe | 12/30/2008 | |
1404 | 11/19/2004 | 904 | 10011946 | Reprogramming the dme after programming interruption. this bulletin replaces bulletin 904 dated 10-7-04. *tt | 02/07/2005 |
EQUIPMENT - ELECTRICAL - AIR CONDITIONER | |||||
0702 | 12/05/2007 | 10023758 | Level adjustment fault code 1772 - pressure sensor signal line -- the diagnosis for level control fault 1772 does not indicate the level control compressor as possible fault cause. *nj | 01/30/2008 | |
EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL | |||||
PI-D47-13 | 07/19/2010 | 10034550 | Porsche: requesting return of part/s to pcna for high pressure pump #9a1 110 315 06. *pe | 12/03/2010 | |
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||||
D76 | 05/08/2008 | 10025182 | Parts withdrawn. porsche cars north americ requests return of the following unit to pcna, but only in cases where the defect is visible: part number 955 110 235 01, description fuel line. *pe | 07/16/2008 | |
0604 | 07/20/2006 | 10020270 | In-tank fuel delivery - diagram. *tt | 08/22/2006 | |
POWER TRAIN | |||||
3965 | 02/09/2005 | 10012770 | Warning message in instrument cluster. 4-wheel drive system faulty. *tt | 03/14/2005 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
304 | 02/09/2005 | 304 | 10011518 | Hard shifting in range first to second. *tt update. *tt | 01/26/2005 |
STEERING | |||||
4405 | 10/24/2005 | 4405 | 10015911 | Shaking in the steering wheel. including 2003 porsche cayenne turbo with increased performance *sc | 08/16/2005 |
4412 | 01/01/2005 | 10012475 | Steering wheel vibration *eh | 03/02/2005 | |
STRUCTURE - BODY - DOOR | |||||
106 | 04/25/2006 | 10019880 | Front door does not close properly. *tt | 05/08/2006 | |
SUSPENSION | |||||
0501 | 03/23/2005 | 0501 | 10015094 | Steering wheel vibration. update. *tt | 05/19/2005 |
TIRES - PRESSURE MONITORING AND REGULATING SYSTEMS | |||||
17-08 | 07/10/2008 | 10025946 | Porsche: tire pressure monitoring system (i-no. 7k3, 7k4). complaint tpm not active after changing wheels. *pe | 09/17/2008 | |
2207 | 07/07/2007 | 10022419 | Tire pressure monitoring system troubleshooting tips. *kb | 08/13/2007 | |
UNKNOWN OR OTHER | |||||
PK-D8-16 | 03/02/2011 | 10038544 | Ready | 06/20/2011 | |
PK-D8-16 | 03/02/2011 | 10038544 | Porsche: information on how to read the vin. *rm | 06/20/2011 | |
VISIBILITY - WINDSHIELD WIPER/WASHER | |||||
1005 | 12/15/2005 | 10018843 | Improving windshield wiper efficiency. *tt | 01/18/2006 | |
VISIBILITY - WINDSHIELD WIPER/WASHER - SWITCH/WIRING | |||||
D77 | 05/21/2008 | 10025186 | Parts withdraw; porsche cars north america requests return of the following units to pcna: part numbers 955 628 320 00 and 955 628 321 00; description tip switch. *pe | 07/16/2008 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
AIR BAGS | ||||||
EA06005 | PORSCHE CARS NORTH AMERICA, INC. | 03/15/2006 | 03/12/2007 | SRS WARNING LIGHT ILLUMINATION | ||
Porsche is initiating a customer notification action to address a condition related to a faulty or loose connector in the side airbag system.porsche's testing has shown that the faulty connector will not prevent side airbag deployment.the faulty connector will cause the circuit resistance to exceed the threshold for illumination of the air bag warning light.porsche has reported a large number of warranty claims for illumination of the air bag warning light and many vehicles have been serviced to correct this condition as described in the cayenne technical information bulletin: group 6, #11/04 airbag warning light activated.porsche will perform this service to all remaining uncorrected vehicles under a new product improvement campaign starting at the end of april 2007.all owners of a subject vehicle built through november 2004 will be notified by porsche to bring the vehicle to a dealer to receive the free modification.vehicles built after november 2004 do not contain the subject connector.in addition, porsche reports that a small number of vehicles built in november and december 2003, may contain an incorrectly manufactured side airbag module.this may also produceillumination of the airbag warning light that would become evident soon after the vehicle is put into service.warranty data indicates that these modules have been corrected and no longer present a risk.porsche has not received any report of non-deployment of the side airbag.the action taken by porsche is sufficient to resolve the issue raised by this investigation.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances. | ||||||
PE05060 | PORSCHE CARS NORTH AMERICA, INC. | 11/10/2005 | 03/15/2006 | SRS WARNING LIGHT ILLUMINATION | ||
During the preliminary evaluation phase, odi identified 76 owner complaints and 6,582 warranty claims related to airbag warning light illumination from either a faulty side-impact airbag module or wiring harness.to date, there has been no allegation of crash, injury or death reported.porsche reports that a bad batch of modules was produced during mid-november to mid-december, 2003.however, porsche | ||||||
AIR BAGS - FRONTAL - SENSOR/CONTROL MODULE | ||||||
EA06005 | PORSCHE CARS NORTH AMERICA, INC. | 03/15/2006 | 03/12/2007 | SRS WARNING LIGHT ILLUMINATION | ||
Porsche is initiating a customer notification action to address a condition related to a faulty or loose connector in the side airbag system.porsche's testing has shown that the faulty connector will not prevent side airbag deployment.the faulty connector will cause the circuit resistance to exceed the threshold for illumination of the air bag warning light.porsche has reported a large number of warranty claims for illumination of the air bag warning light and many vehicles have been serviced to correct this condition as described in the cayenne technical information bulletin: group 6, #11/04 airbag warning light activated.porsche will perform this service to all remaining uncorrected vehicles under a new product improvement campaign starting at the end of april 2007.all owners of a subject vehicle built through november 2004 will be notified by porsche to bring the vehicle to a dealer to receive the free modification.vehicles built after november 2004 do not contain the subject connector.in addition, porsche reports that a small number of vehicles built in november and december 2003, may contain an incorrectly manufactured side airbag module.this may also produceillumination of the airbag warning light that would become evident soon after the vehicle is put into service.warranty data indicates that these modules have been corrected and no longer present a risk.porsche has not received any report of non-deployment of the side airbag.the action taken by porsche is sufficient to resolve the issue raised by this investigation.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances. | ||||||
PE05060 | PORSCHE CARS NORTH AMERICA, INC. | 11/10/2005 | 03/15/2006 | SRS WARNING LIGHT ILLUMINATION | ||
During the preliminary evaluation phase, odi identified 76 owner complaints and 6,582 warranty claims related to airbag warning light illumination from either a faulty side-impact airbag module or wiring harness.to date, there has been no allegation of crash, injury or death reported.porsche reports that a bad batch of modules was produced during mid-november to mid-december, 2003.however, porsche | ||||||
AIR BAGS - SIDE/WINDOW | ||||||
EA06005 | PORSCHE CARS NORTH AMERICA, INC. | 03/15/2006 | 03/12/2007 | SRS WARNING LIGHT ILLUMINATION | ||
Porsche is initiating a customer notification action to address a condition related to a faulty or loose connector in the side airbag system.porsche's testing has shown that the faulty connector will not prevent side airbag deployment.the faulty connector will cause the circuit resistance to exceed the threshold for illumination of the air bag warning light.porsche has reported a large number of warranty claims for illumination of the air bag warning light and many vehicles have been serviced to correct this condition as described in the cayenne technical information bulletin: group 6, #11/04 airbag warning light activated.porsche will perform this service to all remaining uncorrected vehicles under a new product improvement campaign starting at the end of april 2007.all owners of a subject vehicle built through november 2004 will be notified by porsche to bring the vehicle to a dealer to receive the free modification.vehicles built after november 2004 do not contain the subject connector.in addition, porsche reports that a small number of vehicles built in november and december 2003, may contain an incorrectly manufactured side airbag module.this may also produceillumination of the airbag warning light that would become evident soon after the vehicle is put into service.warranty data indicates that these modules have been corrected and no longer present a risk.porsche has not received any report of non-deployment of the side airbag.the action taken by porsche is sufficient to resolve the issue raised by this investigation.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances. | ||||||
PE05060 | PORSCHE CARS NORTH AMERICA, INC. | 11/10/2005 | 03/15/2006 | SRS WARNING LIGHT ILLUMINATION | ||
During the preliminary evaluation phase, odi identified 76 owner complaints and 6,582 warranty claims related to airbag warning light illumination from either a faulty side-impact airbag module or wiring harness.to date, there has been no allegation of crash, injury or death reported.porsche reports that a bad batch of modules was produced during mid-november to mid-december, 2003.however, porsche |