Suzuki Hayabusa 1999
Model Hayabusa made in 1999 by Suzuki got 8 consumer complains as well as 1 recall. Consumer complaints with reference, among others things, to engine and engine cooling and fuel system, gasoline. There was one recall concerning engine and engine cooling .
Model 1999
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | ||||||||||||||||
99V270000 | AMERICAN SUZUKI MOTOR CORP. | from 01/01/1999 to 07/31/1999 | V (Vehicle) | 2670 | 10/13/1999 | MFR | AMERICAN SUZUKI MOTOR CORP. | 10/12/1999 | 10/26/1999 | |||||||
Defect Summary | Vehicle description: motorcycles. the spring in the cam chain tension adjuster can break allowing the cam chain to jump to the wrong position on the cam shaft sprockets. if the chain jumps to the wrong position, severe engine damage could occur causing sudden engine failure. | |||||||||||||||
Consequence Summary | Sudden engine failure could cause the rear wheel to lockup, disturbing the rider's ability to control the motorcycle. | |||||||||||||||
Corrective Summary | Dealers will replace the original cam chain tension adjuster with a revised cam chain tension adjuster. | |||||||||||||||
Notes | Owner notification began october 13, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact suzuki at 1-800-255-2550.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||
10/30/1999 | 6 | 09/01/1999 | |
I noticed a clunk the rear drive hub was damaged. the dealer and am. suzuki agreed to replace the damper, but identified the defective rear hub as cosemetic only and refused to replace it. the cam chain tensioner failed in october 1999 at the same time the fuel injection system-fuel pump screens caused intermittent stalls, surges; the cam chain tensioner was replaced under warranty while the fuel delivery problem has been denied, forcing me to use fuel injection cleaner. cam chain tensioner failed again october 2000, thousand oaks suzuki refused to warranty the recall, am. suzuki claims they will truck it to van nuys suzuki. the front fender cracked at about 2,000 miles, t.o. suzuki ordered new fender, but refused to install it. the sub frames have been breaking, causing many accidents, am. suzuki claim it is only a problem is outside of u.s. and refuse to warranty the sub frame or install safety braces . *ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
10/30/1999 | 6 | 09/01/1999 | |
I noticed a clunk the rear drive hub was damaged. the dealer and am. suzuki agreed to replace the damper, but identified the defective rear hub as cosemetic only and refused to replace it. the cam chain tensioner failed in october 1999 at the same time the fuel injection system-fuel pump screens caused intermittent stalls, surges; the cam chain tensioner was replaced under warranty while the fuel delivery problem has been denied, forcing me to use fuel injection cleaner. cam chain tensioner failed again october 2000, thousand oaks suzuki refused to warranty the recall, am. suzuki claims they will truck it to van nuys suzuki. the front fender cracked at about 2,000 miles, t.o. suzuki ordered new fender, but refused to install it. the sub frames have been breaking, causing many accidents, am. suzuki claim it is only a problem is outside of u.s. and refuse to warranty the sub frame or install safety braces . *ak | |||
POWER TRAIN - AXLE HUBS | |||
10/30/1999 | 6 | 09/01/1999 | |
I noticed a clunk the rear drive hub was damaged. the dealer and am. suzuki agreed to replace the damper, but identified the defective rear hub as cosemetic only and refused to replace it. the cam chain tensioner failed in october 1999 at the same time the fuel injection system-fuel pump screens caused intermittent stalls, surges; the cam chain tensioner was replaced under warranty while the fuel delivery problem has been denied, forcing me to use fuel injection cleaner. cam chain tensioner failed again october 2000, thousand oaks suzuki refused to warranty the recall, am. suzuki claims they will truck it to van nuys suzuki. the front fender cracked at about 2,000 miles, t.o. suzuki ordered new fender, but refused to install it. the sub frames have been breaking, causing many accidents, am. suzuki claim it is only a problem is outside of u.s. and refuse to warranty the sub frame or install safety braces . *ak | |||
POWER TRAIN - CLUTCH ASSEMBLY | |||
When releasing the clutch a banging noise occurs in the clutch assembly. this could eventually cause the motor to lock up. dealer cannot identify the problem. please give any further details.*ak | |||
STRUCTURE - FRAME AND MEMBERS | |||
04/01/2000 | |||
Have seen and read reports that the aluminum subframe on this '99 motorcycle is unsafe. it is suspected that this critical component will fail with greater frequency over time due to fatique. nlm | |||
06/01/1999 | |||
I would like to bring to your attention of improper welding of the aluminum subframe ( located under passenger seat ) on the '19992000 suzuki hayabusa. there have been incidents of the subframe breaking at the welds, from what i understand suzuki is not taking responsibility on any type of recall. however on th 2001 & 2002 models they made them with a steel subframe.more accidents are waiting to happen if this problem doesn't get resolved.suzuki needs to take responsibility.*ak | |||
08/01/1999 | |||
As i have said my subframe has not failed yet but others have, this is very dangerous, please look into this, suzuki is doing nothing about this in the u.s.a. but they have recalled and replaced them in the u.k. why only in the u.k. ? thank you nlm | |||
09/01/2001 | |||
Interested in possible recall campign with suzuki; no personal failures, but a disproportionate number of others have had this failure occur. no safety defect listed. *ak |