Fleetwood Discovery 2005
Model Discovery made in 2005 by Fleetwood got 36 consumer complains, 1 investigation there are 2 recalls as well as 1 service bulletin. Consumer complaints with reference, among others things, to electronic stability control, ity/wiper (pws) and structure. Technical service bulletines regarding latches/locks/linkages. The car had one investigation (equipment). There was one recall concerning equipment .
Model 2005
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EQUIPMENT - OTHER - LABELS | ||||||||||||||||
| 05V333000 | FLEETWOOD ENTERPRISES, INC. | from 06/01/2004 to 04/11/2005 | V (Vehicle) | 2435 | 08/04/2005 | MFR | FLEETWOOD ENTERPRISES, INC. | 07/27/2005 | 07/27/2005 | 567 | ||||||
| Defect Summary | Certain diesel class a motor homes fail to comply with the requirements of part 567, certification. the manufacturers' tow hitch receiver information label was printed with the incorrect weight carrying capacity value and the incorrect tongue weight value. | |||||||||||||||
| Consequence Summary | The weight label on the hitch receiver provides the maximum trailer weight rating and the maximum tongue weight rating. it is important that these ratings not be exceeded. failure to comply could result in damage to the motor home frame, body, or hitch receiver and could cause unstable driving and handling characteristrics which may result in a vehicle crash. | |||||||||||||||
| Corrective Summary | Fleetwood will mail owners the correct tow hitch receiver weight information label. if owners do not feel comfortable installing the label, dealers will install the label for them. the recall began august 4, 2005. owners may contact fleetwood at 800-509-3418. | |||||||||||||||
| Notes | Fleetwood recall no. 50719. customers may also contact the national highway traffic safety administration | |||||||||||||||
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 08V320000 | FLEETWOOD ENTERPRISES, INC. | from 04/01/2003 to 11/30/2006 | V (Vehicle) | 70101 | 10/24/2008 | ODI | FLEETWOOD ENTERPRISES, INC. | 07/15/2008 | 07/15/2008 | |||||||
| Defect Summary | Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. the refrigerator may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
| Consequence Summary | If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire. | |||||||||||||||
| Corrective Summary | Fleetwood is working with dometic to repair these refrigerators (please see 08e032). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| LATCHES/LOCKS/LINKAGES | |||||
| 0272 | 03/01/2007 | 10022625 | Travel lock repairs for full wall slide - out. conditions for replacement damaged travel lock feet, damaged travel locks, inoperative travel locks, or uneven travel lock landing pads. *kb | 09/12/2007 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||
| PE06005 | FLEETWOOD ENTERPRISES, INC. | 01/20/2006 | 05/02/2006 | INADVERTENT SLIDE-OUT EXTENSION MOVEMENT | ||
| This investigation was opened based on odi's receipt of a congressional letter on behalf of a constituent.the constituent reported incidents where the slide out room of his motor home would inadvertently move (extend) during highway use.odi was concerned that a fully extended slide out would degrade the vehicle's dynamic handling characteristics and/or possibly impact an object or another vehicle, resulting in a crash.odi contacted fleetwood and discovered that slide out rooms were installed in motor homes, travel trailers and folding trailers. as part of the investigation odi visited a rv show and the fleetwood paxinos plant to examine slide outs in various new make and model vehicles and gain an understanding of how the systems work.during the investigation odi learned that there are two methods used to extend slide out rooms.some manufacturers use hydraulic systems and others, such as fleetwood, use an electric motor. (continued on page 2) | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRONIC STABILITY CONTROL | |||
| 01/07/2008 | |||
| Our windows are fogged very bad.when the sun is out the glare is so bad that u can not see out to see the mirrors ,very dangerous.when i called to complain they said i called to late for them to be repaired,they did not send a recall.called fleetwood a few times and they would not stand behind it nor would my dealer.they new they had a problem and would not fix it. | |||
| ITY/WIPER (PWS) | |||
| 05/01/2009 | 5000 | ||
| Tl* the contact owns a 2005 fleetwood discovery. while the vehicle was parked the contact noticed the front driver and passenger side windows were fogged making it impossible for him to see through the windows. the vehicle was taken to the dealer for diagnostic testing. the technicians contacted the manufacturer and they replaced the driver and passenger side windows. the failure occurred a second time approximately one year after the windows were replaced. the vehicle was not repaired. the approximate failure mileage was 5,000. | |||
| 05/01/2009 | 5000 | ||
| Tl- the contact owns a 2005 fleetwood discovery. while the vehicle was parked the contact noticed the front driver and passenger side windows were fogged making it impossible for him to see through the windows. the vehicle was taken to the dealer for diagnostic testing. the technicians contacted the manufacturer and they replaced the driver and passenger side windows. the failure occurred a second time approximately one year after the windows were replaced. the vehicle was not repaired. the approximate failure mileage was 5,000. rvk | |||
| 05/01/2009 | 5000 | ||
| Tl- the contact owns a 2005 fleetwood discovery. while parked the contact noticed the front driver and passenger side windows were fogged making it impossible for him to see through the windows. the vehicle was taken to the dealer for diagnostic. the technicians contacted the window manufacturer and the front driver and passenger side windows were replaced. the failure occurred a second time approximately one year after the replacement. the vehicle was not repaired. the approximate failure mileage was 5,000. da | |||
| STRUCTURE | |||
| 05/01/2005 | 0 | 0 | 03/26/2005 |
| Freightliner chassis has rust all over chassis. chassis is part of a fleetwood rv motorhome. fleetwood and freightliner keeps saying this is not their problem. why is it my problem when this was supposed to be a new motorhome? i believe this unit was in water. *nm | |||
| STRUCTURE - BODY | |||
| 11/02/2008 | 35113 | 1 | |
| Roof water intrusion into interior of rv rear view mirror chrome failure drivers side window seals failure allowing fogging to occur. *tr | |||
| UNKNOWN OR OTHER | |||
| 01/07/2008 | |||
| Our windows are fogged very bad.when the sun is out the glare is so bad that u can not see out to see the mirrors ,very dangerous.when i called to complain they said i called to late for them to be repaired,they did not send a recall.called fleetwood a few times and they would not stand behind it nor would my dealer.they new they had a problem and would not fix it. | |||
| 02/18/2009 | 19000 | ||
| Double pane windows fogging from between the panes. | |||
| VISIBILITY | |||
| 10/20/2008 | 4800 | ||
| Tl- the contact owns a 2005 fleetwood discovery rv. the contact stated that the side windows would become extremely foggy, making it difficult to see the side mirror when attempting a turn or to see any vehicle from the left. the dealer and manufacturer were contacted and denied any assistance with repairs to the vehicle. the vehicle was not repaired. the failure mileage was 4,800 and the current mileage was 15,000. the vin was unavailable. kmj | |||
| 10/20/2008 | 4800 | ||
| Tl- the contact owns a 2005 fleetwood discovery. the contact stated that the side windows would fog up, making it see the side mirror to make a turn or to see vehicle on the left side of the vehicle. the dealer and manufacturer denied any assistance with repair to the vehicle. the vehicle was not repaired. the failure mileage was 4,800 and the current mileage was 15,000. the vin was unavailable. nw | |||
| 01/07/2008 | |||
| Our windows are fogged very bad.when the sun is out the glare is so bad that u can not see out to see the mirrors ,very dangerous.when i called to complain they said i called to late for them to be repaired,they did not send a recall.called fleetwood a few times and they would not stand behind it nor would my dealer.they new they had a problem and would not fix it. | |||
| 02/15/2010 | 18500 | 1 | |
| I have a 2005 discovery motorhome manufactured by fleetwood. the dual paned drivers side window which was manufactured by se gi has failed and is fogging up which is impacting visibility to the side view mirror. i am also stating to see similar failures on several of the stationary windows in the back of the motorhome. in my opinion these failures are premature. *tr | |||
| 04/15/2007 | 1 | ||
| We are experiencing clouding/fogging of all of the side windows on our 2005 fleetwood discovery. it has been progressing slowly over the past year or so. the clouding is severe to the point that it is interfering with viewing my side mirror. *tr | |||
| 01/01/2007 | 10000 | 1 | |
| I have a 2005 fleetwood discovery 39l class a motor home. several of the windows on this coach are fogging up, and cannot be cleaned to clear up the haze. one of the worst window is the passenger side window. this makes vision thru the window poor, and i feel that it is a safety hazard. i have read that many other people have had similar problems with the same year/model as mine. also it appears that fleetwood is aware of these problems and has changed suppliers of windows for their vehicles as a result. this condition has been worsening for the last couple of years. i feel that a recall for these windows is in order. i would appreciate it if something could be done to remedy this problem before any of these vehicles are involved in an accident due to the windows. *tr | |||
| 05/19/2009 | 1 | ||
| I own a 2005 fleetwood discovery motor home and every window in it had fogged up. of course, the most dangerous being the drivers side window. after calling fleetwood and they referred me to segi the window manufacturer i found out neither of them would assist me with the problem. i researched and found a repair facility in hudson, fl., suncoast design that would repair them for $200.00 per frame. i chose to repair seven of the windows. they did a superb job but i still feel i should not have had to incur the expense. *tr | |||
| 02/20/2009 | 28000 | 1 | |
| The stationary window on the drivers side of our motorhome is fogging up very badly. it is bad enough right now that it is difficult to be able to see through it and to be able to see the rear view mirror. the window glass is made by a company named se-gi. i have read about lots and lots of other fleetwood vehicle owners who have experienced this same terrible problem. i understand that the company is or has already closed for business. fleetwood will no longer do anything as the basic 12 month warranty period has already expired. we have since noticed that one other stationary window has began to fog up. we had one smaller window that is the type that you crank it outward to open it up. it is one that is roughly 24-26 inches wide and about 6 inches high. well that sucker totally fell out as we were driving along the interstate. we were not able to recover that window and this also happened after our warranty had expired. i have heard of other people having similar such incidents. it certainly seems to me that any company that manufactures vehicles that cost an average of well over $200k, that they would perfect the process so that they are not dealing with substandard quality materials and workmanship. *tr | |||
| VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||
| 06/01/2008 | 14500 | 1 | |
| Segi windows in fleetwood motor home are fogging up making it hard to see rear view mirrors. this may be a safety hazard. *tr | |||
| VISIBILITY/WIPER | |||
| 11/01/2012 | 25000 | 1 | |
| Side windows are fogging up and cannot be cleaned. the worst is the drivers side windows and it is very difficult to see the mirrors which of course becomes very dangerous. both the manufacturer and original suppliers (from reports by others) state this is past the warranty period. this is without a doubt a safety issue as the drivers sight is restricted. *tr | |||
| 11/01/2012 | 25000 | ||
| Side windows are fogging up and cannot be cleaned. the worst is the drivers side windows and it is very difficult to see the miors which of course becomes very dangerious. both the manufactuter and origional suppliers (from reports by others) state this is past the warranty period. this is without a doubt a saftey issue as the drivers sight is restricted. | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| TN | NASHVILLE | 37214 | BANKSTON MOTOR HOMES | 615-883-6800 |