Fleetwood Pace Arrow 2002
Model Pace Arrow made in 2002 by Fleetwood got 6 consumer complains, 1 investigation there are 4 recalls as well as 2 service bulletins. Consumer complaints with reference, among others things, to equipment, service brakes, hydraulic and suspension. Technical service bulletines regarding engine and engine cooling. The car had one investigation (equipment). There were some recalls concerningequipment, service brakes, air and service brakes, hydraulic.
Model 2002
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EQUIPMENT | ||||||||||||||||
| 09V312000 | FLEETWOOD RV, INC. | from 07/13/2001 to 12/26/2002 | V (Vehicle) | 6684 | 06/26/2009 | MFR | FLEETWOOD ENTERPRISES, INC. | 07/28/2009 | 07/30/2009 | |||||||
| Defect Summary | Fleetwood rv is recalling certain model year 2005 and 2006 motorhomes manufactured between july 24, 2004 and march 11, 2005, equipped with norcold model 1200lr, 1200lrim, and 1201lrim refrigerators with serial numbers between 1273701 and 1536607, non-consecutively. a fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. if a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. at such high temperatures, the cooling unit could rupture. | |||||||||||||||
| Consequence Summary | If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. | |||||||||||||||
| Corrective Summary | Fleetwood rv will notify owners and the vehicle's refrigerator will be repaired free of charge. the safety recall is expected to begin during september 2009. owners may contact fleetwood rv at 1-800-509-3418 or norcold's recall center at 1-800-767-9101. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 07V120000 | FLEETWOOD ENTERPRISES, INC. | from 04/01/1997 to 07/31/2003 | V (Vehicle) | 167096 | 05/10/2007 | MFR | FLEETWOOD ENTERPRISES, INC. | 03/19/2007 | 03/20/2007 | |||||||
| Defect Summary | Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
| Consequence Summary | Release of coolant under certain conditions could ignite and result in a fire. | |||||||||||||||
| Corrective Summary | Fleetwood will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. | |||||||||||||||
| Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
| SERVICE BRAKES, AIR | ||||||||||||||||
| 09V198000 | FLEETWOOD ENTERPRISES, INC. | V (Vehicle) | 509 | 05/01/2009 | ODI | FLEETWOOD ENTERPRISES, INC. | 06/02/2009 | 06/01/2009 | ||||||||
| Defect Summary | Fleetwood is recalling 509 my 2001-2008 class a motor homes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. when combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. this can result in abnormal heat generation at the wheel end causing brake drag. the driver would normally have warning of the brake drag if undetected by the driver. | |||||||||||||||
| Consequence Summary | The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. | |||||||||||||||
| Corrective Summary | Dealers will inspect and replace the necessary components free of charge. workhorse is handling the remedy for this campaign please see 09v-110. the manufacturer has not yet provided an owner notification schedule. owners may contact workhorse at 1-877-246-7731. workhorse will conduct the owner and dealer notification. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING | ||||||||||||||||
| 03V066000 | FLEETWOOD ENTERPRISES, INC. | from 09/17/1999 to 08/30/2001 | V (Vehicle) | 11194 | 04/07/2003 | MFR | FLEETWOOD ENTERPRISES, INC. | 03/04/2003 | 03/17/2003 | 571 | 105 S5.3 | |||||
| Defect Summary | Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, hydraulic and electric brake systems. the brake system warning indicator may not function as required by standard. | |||||||||||||||
| Consequence Summary | In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator. | |||||||||||||||
| Corrective Summary | Dealers will repair these vehicles. owner notification began april 7, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact fleetwood at 1-800-445-3307. | |||||||||||||||
| Notes | Fleetwood recall no. 30312.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| SBM0068 | 09/01/2001 | 626353 | Subject regarding compass and outside temperature system calibration. *yd | 12/13/2001 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 0251 | 12/01/2004 | 10014720 | Air intake baffle procedure/installation which may be susceptible to stalling or sputtering during heavy rains or when water is sprayed directly at the front end. the check engine light may illuminate also. various models including fleet | 05/06/2005 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||
| PE06005 | FLEETWOOD ENTERPRISES, INC. | 01/20/2006 | 05/02/2006 | INADVERTENT SLIDE-OUT EXTENSION MOVEMENT | ||
| This investigation was opened based on odi's receipt of a congressional letter on behalf of a constituent.the constituent reported incidents where the slide out room of his motor home would inadvertently move (extend) during highway use.odi was concerned that a fully extended slide out would degrade the vehicle's dynamic handling characteristics and/or possibly impact an object or another vehicle, resulting in a crash.odi contacted fleetwood and discovered that slide out rooms were installed in motor homes, travel trailers and folding trailers. as part of the investigation odi visited a rv show and the fleetwood paxinos plant to examine slide outs in various new make and model vehicles and gain an understanding of how the systems work.during the investigation odi learned that there are two methods used to extend slide out rooms.some manufacturers use hydraulic systems and others, such as fleetwood, use an electric motor. (continued on page 2) | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| EQUIPMENT - RECREATIONAL VEHICLE | |||
| 08/25/2004 | 1 | ||
| Vehicle was built with gas generator. while the generator was on the metal exhaust pipe make contact with a plastic storage, causing the plastic to melt. this could develop into a fire. *ak | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 11/10/2008 | 17010 | 1 | |
| November of 2008, i was driving through lake worth, florida when my front brakes on my 2002 pace arrow motor home started to heat up and smoke. upon inspection i found the brakes red hot at the steer axle. while doing a internet search for parts,i found a rv blog site with over 80 pages of complaints about the w22 workhorse chassis which i have. i also learned about a recall by workhorse. after calling workhorse they told me the update had been done by the previous owner at 12,000 mi. it now has 17,000 mi. and i see the update didn't work. i have replaced the wheel seals, oil hub caps, and rebuilt the calipers on both steer axles. judging by the blogs there are a lot of angry w22 workhorse chassis owners not getting much results from the manufacturer. this is a safety issue that should be resolved before people get injured or killed. the repairs done seem to be a temporary fix as best as many owners have had multiple brake failures. the cost to me was about $400.00. i do have the some of the old parts. i forgot to mention that the antilock brake sensors melted also. i fear going back out on the road that you never know when the next failure will be or what the results will be. i was lucky to be in slow traffic , but what about next time? thank you. *tr | |||
| 10/07/2004 | 4 | ||
| Customer claim about recall campaign work which was not properly completed and put him in precarious safety situations and cost him money. customer wants concerns reviewed**cc the consumer stated the defect involved the brake caliper hanging in a partial apply position, which became extremely hot and caused severe damage to brake parts. the consumer stated the abs light would illuminate. the consumer had been to several dealers and upon inspection it was discovered the rotors were cracked, on another occasion the driver side sensor was loose all of which was related to the recall. *jb | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 11/30/2001 | 100 | 11/01/2001 | |
| The unit is topping out against the shocks when the vehicle goes over a series of bumps. it seems as if the unit is too light in the front end. there is a 14 foot overhang from the bumper to the center-rear axel. wheel base is 228 inches and the total length of the coach is 37'11. the braking system shakes like crazy and doesn't slow the unit down. this failure is random and there are no consistent conditions under which this failure occurs. the dealer has investigated this problem and cannot find anything wrong with the brakes. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
| 12/26/2007 | 13538 | 1 | 09/18/2004 |
| While driving on december 26,2007 we felt a drag on the unit and we were aware of an odor indicating something was hot. we stopped and checked into a campground. as we backed into the site and put on the brake it went to the floor, no brakes. engine area we observed fluid was splattered under the hood. brake fluid had blown out of the top of the brake fluid container. we were able to get into a garage on saturday 29th. and advised the the problem was with the calipers and that we needed new brake calipers and probably should replace the master cylinder. it was saturday and the master cylinder was not available so only the calipers were replaced. we have no pictures but we do have the old calipers. we contacted workhorse but sent a form letter telling us how to use the brakes and that the coach was out of warranty and they were not responsible for any further reimbursement. *tr | |||
| SUSPENSION - FRONT - SHOCK ABSORBER | |||
| 11/30/2001 | 100 | 11/01/2001 | |
| The unit is topping out against the shocks when the vehicle goes over a series of bumps. it seems as if the unit is too light in the front end. there is a 14 foot overhang from the bumper to the center-rear axel. wheel base is 228 inches and the total length of the coach is 37'11. the braking system shakes like crazy and doesn't slow the unit down. this failure is random and there are no consistent conditions under which this failure occurs. the dealer has investigated this problem and cannot find anything wrong with the brakes. | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| MT | BUTTE | 59701 | BUTTE | 406-494-3031 |