Rialta Rialta 2002
Model Rialta made in 2002 by Rialta got 5 consumer complains, 2 investigations there are 3 recalls as well as 3 service bulletins. Consumer complaints with reference, among others things, to engine and engine cooling, fuel system, other and power train. Technical service bulletines regarding engine and engine cooling. The car had one investigation (engine and engine cooling). There were some recalls concerningequipment, trailer hitches and wheels.
Model 2002
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
03V405000 | WINNEBAGO INDUSTRIES, INC. | from 05/01/2000 to 10/31/2003 | V (Vehicle) | 15337 | ODI | WINNEBAGO INDUSTRIES, INC. | 10/16/2003 | 10/22/2003 | ||||||||
Defect Summary | On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads. | |||||||||||||||
Consequence Summary | An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire. | |||||||||||||||
Corrective Summary | Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or winnebago at 641-585-3535. | |||||||||||||||
Notes | Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
TRAILER HITCHES | ||||||||||||||||
02V153000 | WINNEBAGO INDUSTRIES, INC. | from 01/16/2002 to 03/13/2002 | V (Vehicle) | 229 | 06/21/2002 | MFR | WINNEBAGO INDUSTRIES, INC. | 06/12/2002 | 06/13/2002 | |||||||
Defect Summary | On certain motor homes, an improperly mounted trailer hitch may have been installed on these motor homes. the trailer hitch may not have all the required fasteners attached to the motor home. | |||||||||||||||
Consequence Summary | If the hitch is utilized, it could stress the existing fasteners. a condition could exist that would shear or loosen the remaining fastener causing the hitch to separate from the vehicle, resulting in bodily injury and/or property damage. | |||||||||||||||
Corrective Summary | Dealers will inspect the trailer hitch, and if necessary, add or replace the mounting hardware. owner notification began june 21, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-6939. | |||||||||||||||
Notes | Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
WHEELS - CAP/COVER/HUB | ||||||||||||||||
01V298000 | WINNEBAGO INDUSTRIES, INC. | from 02/01/2001 to 06/22/2001 | V (Vehicle) | 396 | 10/18/2001 | MFR | WINNEBAGO INDUSTRIES, INC. | 09/15/2001 | 10/01/2001 | |||||||
Defect Summary | Vehicle description: motor homes (models 222fd, 222qd, and 222hd). the wheel cover can rotate while mounted on the wheel. | |||||||||||||||
Consequence Summary | If the cover rotates to the valve stem, a condition exists that could shear the valve stem off, leading to a rapid deflation of the tire. this rapid tire air loss could cause the driver to lose control of the vehicle, potentially resulting in a crash. | |||||||||||||||
Corrective Summary | Dealers will replace the rubber valve stems and wheel covers. owner notification began october 18, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-6939. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||||
0402 | 04/15/2004 | 10007297 | Radiator fan damaged caused by improperly supporting the radiator assembly when repairs require the radiator to be pivoted forward. *tt | 06/09/2004 | |
VJ | 04/01/2004 | 10007004 | The radiator fans can be damaged if the proper tool is not used to hold the radiator assembly in the service position. service action to alert service personnel by affixing a radiator fan service position warning label in the engine compar | 05/21/2004 | |
0401 | 02/06/2004 | 10006055 | Radiator fan damaged caused by improperly supporting the radiator assembly when repairs require the radiator to be tipped forward. *tt | 04/13/2004 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | ||||||
RQ07002 | WINNEBAGO INDUSTRIES, INC. | 09/05/2007 | 01/04/2008 | ENGINE COOLING FAN BLADE FRACTURE | ||
The office of defects investigation (odi) opened this investigation based on four reportsalleging failure of an engine cooling fan in the subject vehicles.three of the complainants alleged the fan disintegrated and two of the three alleged the radiator was damaged as a result.the fourth complainant alleged that his vehicle experienced violent shaking and overheating.when the vehicle was inspected, it was noted that pieces of the fan were missing.all four vehicles were class c motor homes built on a volkswagen eurovan chassis.two of the vehicles are rialta models and two are vista models.based onadditional information received from volkswagen odi is upgrading this investigation toengineering analysis ea 08-002 for further study. | ||||||
EA08002 | WINNEBAGO INDUSTRIES, INC. | 01/04/2008 | 03/14/2008 | ENGINE COOLING FAN BLADE FRACTURE | ||
The subject vehicles are built on a volkswagen eurovan chassis and are class c motor homes. on september 5, 2007, the office of defects investigation (odi) opened this investigation as rq 07-002 after receiving four consumer reports of fan blade failure on model year 2002 winnebago rialta and vista vehicles.as a result of additional information received from volkswagen in response to rq 07-002, the investigation was upgraded to engineering analysis (ea) 08-002.the scope of the ea investigation was also expanded to cover model years 2001 through 2004 rialta and vista, 2002 through 2004 sunstar, and 2001 through 2003 eurovan.all of these vehicles utilize the same engine cooling fan.however, the winnebago vehicles are larger and heavier than the eurovan.as a consequence, the cooling fan would operate more frequently in the winnebago vehicles compared to the eurovan for the same on-road operating conditions.analysis of the available data concerning the problem experience indicates that it predominately affects the my 2002 winnebago models.winnebago accounts for 79% of all the reports, but represents only 23% of the total subject vehicle population.the majority of the winnebago reports are for the model year 2002 (64%).the data show a declining report trend, particularly for the 2002 winnebago.reports on the 2002 winnebago reached a high of 11 reports in calendar year 2005, dropping to three reports in 2006,two reports in 2007, and one report in 2008.an existing safety related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that a safety-related defect does not exist.the agency will take further action if warranted by the circumstances. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||
09/04/2007 | 14400 | 1 | 02/01/2007 |
Tl*the contact owns a 2002 winnebago rialta. while driving 55 mph, the contact heard a loud clunking noise coming from the engine compartment. the vehicle then overheated. the mechanic stated that the electrical cooling fan blades fractured and separated, however, they were unable to determine the cause of failure. the manufacturer stated that his vin was excluded from nhtsa campaign id number 04v107000 (engine and engine cooling: cooling system: fan). the failure mileage was 14,400 and current mileage was 14,550. updated 10/24/07. *jb | |||
07/08/2003 | 7449 | 1 | 01/09/2003 |
Problems with vehicle cooling fan. *mr there was an engine noise along with shaking, vibrations, and the section of the fan on the drivers side was found missing. both of the cooling fans were replaced. (the fins were cracked) winnebago/rialta *scc *jb | |||
FUEL SYSTEM, OTHER | |||
04/23/2002 | 1 | 04/06/2002 | |
Fuel gauge reads incorrectly, when there is 1/4 tank the gauge reads 3/4. dealer has not inspected vehicle, winnebago and volkswagen cannot decide who is responsible for this problem.*jb the fuel gauge showed wrong reading because it was installed incorrectly. *yh | |||
POWER TRAIN - AXLE ASSEMBLY | |||
11/28/2003 | 17000 | 1 | 05/01/2003 |
While driving at 70 mph spindle and axle broke off. as a result, vehicle veered across the median into an embankment. consumer is still awaiting for vehicle parts to repair vehicle.*ak *mr | |||
SUSPENSION - REAR - AXLE - SPINDLE | |||
11/28/2003 | 17000 | 1 | 05/01/2003 |
While driving at 70 mph spindle and axle broke off. as a result, vehicle veered across the median into an embankment. consumer is still awaiting for vehicle parts to repair vehicle.*ak *mr |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
CA | RIVERSIDE | RICHARDSON'S RV | ||
CA | SCOTTS VALLEY | 95066 | MERRITT RV'S | 831 461 1777 |
FL | SEFFNER | LAZY DAYS |